Philips Trim 1 Service Manual

7
7-1
Chapter 7Removing and Replacing
Cardiograph Components
This chapter contains information on removing and replacing the PageWriter Trim 
cardiograph battery, fuses, and paper tray. If you require further technical assistance, contact 
the nearest Philips Response Center. See “Contacting a Philips Response Center” on 
page 1-32.
About the Cardiograph Components
The cardiograph includes the following customer-installable components. 
„Battery compartment
„AC fuses
„Paper tray 

Removing and Replacing Cardiograph ComponentsRemoving and Replacing the Battery
7-2PageWriter Trim Cardiograph Service Manual 
Removing and Replacing the Battery
All of the PageWriter Trim cardiograph models use the same single battery (part number 
989803130051). Removal and replacement procedures are the same for all models.
Removing the Battery 
To remove the battery:
1
Unplug the AC power cord. 
Make sure the green AC power indicator light is not illuminated. 
Figure 7-1 AC power light
For an...

Removing and Replacing Cardiograph ComponentsRemoving and Replacing the AC Fuses
PageWriter Trim Cardiograph Service Manual7-3
WARNINGProperly dispose or recycle any depleted batteries according to local regulations. 
Do not disassemble, puncture, or incinerate the batteries.
Replacing the Battery
To replace the battery:
1
Insert the new battery into the battery slot, and push it in until it clicks into place. 
2Re-attach the battery door.
Removing and Replacing the AC Fuses 
The AC fuse needs to be...

Removing and Replacing Cardiograph ComponentsRemoving and Replacing the Paper Tray
7-4PageWriter Trim Cardiograph Service Manual 
Removing and Replacing the Paper Tray
The paper tray is the same for all PageWriter Trim models. 
Removing the Paper Tray
To remove the paper tray:
1
Pull out the paper tray until it stops. 
2Remove any unused paper.
3Carefully lift tray, and pull it out completely.
Replacing the Paper Tray
To replace the paper tray:
1
Insert the paper tray into the opening. 
2Replace the...

8
8-1
Chapter 1Parts and Accessories
This chapter provides information on ordering replacement parts that are intended for 
installation by the customer, and other supplies, and accessories for the PageWriter Trim 
cardiographs. It shows illustrated, detailed views of each of the PageWriter Trim 
subassemblies, together with each element’s part number to facilitate part ordering.
Ordering Replacement Parts
To order replacement parts, use prefix number 45.
In the US, call 877-447-7278 
Outside the US,...

Parts and AccessoriesPatient Interface Module (PIM) Assembly and Parts
8-2PageWriter Trim Cardiograph Service Manual
Patient Interface Module (PIM) Assembly and Parts 
Figure 8-1 Patient Interface Module (PIM) Assembly Parts
Table 8-1 Patient Interface Module (PIM) Assembly Parts
Reference Number Description Part Number
1 Patient Data Cable Replacement Kit 453564034571
2 Patient Interface Module (PIM) PCA Set 453564044081 

Parts and AccessoriesCart Assembly and Parts
PageWriter Trim Cardiograph Service Manual8-3
Cart Assembly and Parts
Figure 8-2 Cart Assembly
Table 8-2 Cart Assembly Parts List
Reference Number Description Part Number
1 Rear Handle Kit 453564054341
2 Swivel Caster Kit 453564050721
3 Locking Caster Kit 453564054301
4 Directional Locking Caster Kit 453564054291
5 Cart Base Kit (includes all four casters shown) 453564054311
6 Front Handle Kit 453564054331
7 Cart Upper Housing Kit 453564054321 
Not shown...

Parts and AccessoriesCart Assembly and Parts
8-4PageWriter Trim Cardiograph Service Manual 

A
A-1
Appendix BInstalling PageWriter Trim I Software
A software installation procedure takes approximately fifteen minutes to complete.
Software Upgrades
The upgrade path for a specific cardiograph is dependent upon the software version that is 
currently installed on the unit. Philips recommends that all cardiographs be upgraded to 
software version A.01.03 for optimal performance. See Table A-1 for more information on the 
appropriate upgrade path. 
Upgrading Legacy Software
Legacy software is defined...

Installing PageWriter Trim I SoftwareObtaining Software
A-2PageWriter Trim Cardiograph Service Manual
Software Revision Information 
Table  A-2 provides detailed software revision information. 
Follow the same procedure to upgrade the software in an existing working unit or to install 
software on a new system. 
Obtaining Software 
The software installation procedure requires the use of a computer with a compatible PCMCIA 
card slot, and internet access. The procedure also requires the use of a blank...