Land Rover Defender Workshop Rover Manual

CHASSISANDBODY
25
REPAIR
REAR
ENDLINING -90/110 STATION WAGON
Service repairno-76.64.12
Remove 1. Remove rearendtrimpanel
See Rear end
trim panel
.
2. Remove reargrab handles
See Rear grab
handle
.
3. Carefully priseout6trim studs securing rearend
lining tomounting brackets.
4. Remove rearendlining.
Refit 5. Position rearendlining onmounting brackets
and secure with6trim studs.
6. Fitrear grab handles
See reargrab handle.
7. Fitrear endtrimpanel
See rearendtrim.   

76CHASSIS
ANDBODY
26 REPAIR
FRONT
HEADLINING -90 STATION WAGON
Service repairno-76.64.10
Remove 1. Remove sunroof headlining finisher.
2. Remove sunvisors
See Sunvisors.
3. Remove interiorlamp
SeeELECTRICAL,
Repair, Interiorlamp
.
4. Remove interiormirrorandmounting plate
See
Interior mirror
.
5. Remove 4retaining screwsanddetach bothA
post trims.
6. Remove capsandunscrew frontseatbeltfixing
bolts fromBposts. 7.
Carefully prisesidetrimpanel capfastener from
B posts.
8. Carefully prise2cap fasteners,...

CHASSISANDBODY
27
REPAIR
REAR
HEADLINING -90 STATION WAGON
Service repairno-76.64.11
Remove 1. Remove sidetrimpanels
See Side trimpanel.
2. Remove rearendlining
See Rear endlining.
3. Remove rearinterior lamp
SeeELECTRICAL,
Repair, Interiorlamp
.
4. Carefully priseout5trim studs securing rearand
front headlining toroof mounting brackets. 5.
Release frontcorners ofheadlining fromcant
rail, onboth sides.
6. Pull headlining forwardssufficiently toclear rear
end lining mounting brackets.
7. Release...

76CHASSIS
ANDBODY
28 REPAIR
TAIL
DOOR TRIMCASING
Service repairno-76.34.09
Remove
1. Unscrew 2bolts andremove grabhandle from
rear door.
2. Remove 2screws anddetach wipermotor cover.
3. Remove 7screws securing trimcasing todoor.
4. Remove 2screws andliftwiper motor harness
cover fromharness supportbracket.
5. Carefully release8clips securing trimcasing to
door.
6. Remove trimcasing andcollect doorlockcover.
Refit 7. Position doorlockcover, fittrim casing and
secure withclips.
8. Fitharness coverandsecure...

CHASSISANDBODY
29
REPAIR
TAIL
DOOR STRIKER -ADJUST
Service repairno-76.37.25
Adjust
1. Loosen strikersecuring screws.
2. Adjust strikerandretighten screws.
3. Close doorandcheck forcorrect latching with
door lock.
4. Carry outfurther adjustment asnecessary. Iffull
adjustment cannotbeachieved carryout
following:
5. Remove strikerandnutplate.
6. Elongate holesinbody metal which is
sandwiched betweenstrikerandnutplate.
7. Refit striker andadjust asnecessary.   

76CHASSIS
ANDBODY
30 REPAIR
SUN
ROOF
Service repairno-76.83.01
Remove 1. Open sunroof fully.
2. Disengage springlockfrom operating handle
catch.
3. Holding sunroof atboth sides, release hinges
from locating brackets atfront ofouter frame. 4.
Remove sunroof.
5. Starting fromcentre rear,peelheadlining finisher
from inner frame.
6. Remove 18screws securing innerframe toouter
frame anddetach innerframe.
7. Lift outer frame fromroof.
NOTE: Assistance mayberequired to
remove thesun roof assembly.
Refit
8....

CHASSISANDBODY
31
REPAIR
INTERIOR
MIRROR
Service repairno-76.10.51
Remove
1. Prise interior mirrorarmfrom mounting plate.
2. Remove 3screws andremove mounting plate
from headlining.
Refit 3. Fitmounting platetoheadlining.
4. Locate lowerlugofmirror arminmounting plate
aperture.
5. Press mirror armfirmly toengage springclipin
mounting plateaperture. SUN
VISORS
Service repairno-76.10.47
Remove
1. Raise sunvisor.
2. Remove 2screws andcollect sunvisor.
Refit 3. Position sunvisor andsecure with2screws.    

76CHASSIS
ANDBODY
32 REPAIR
BONNET
LOCK
Service repairno-76.16.21
Remove 1. Open bonnet.
2.Mark position ofguide plateandlock tobonnet
platform.
3. Remove 8screws securing grille.
4. Remove grille.
5. Remove 2bolts securing guideplateandlock.
6. Remove guideplate.
7. Release springsecuring locktobonnet platform.
8. Slacken clamping boltsecuring bonnetrelease
cable.
9. Remove lock.
Refit 10. Fitspring between lockandbonnet platform.
11. Position lockandguide platetobonnet platform
and nipupbolts.
12....

CHASSISANDBODY
33
REPAIR
17.
Fitcable tolock andtighten clamping bolt.
18. Check operation ofrelease cableandbonnet
lock andadjust ifnecessary.
19. Fitgrille andtighten screws.
20. Close bonnet.  

76CHASSIS
ANDBODY
34 REPAIR
LOWER
FASCIAPANEL(HEATER DUCT)
ASSEMBLY Service repairno-76.46.05
Remove
1. Disconnect battery.
2. Remove steeringwheel
SeeSTEERING,
Repair, Steering wheel
.
3. Remove steeringcolumnnacelle
See
STEERING, Repair,Steering columnnacelle
.
4. Remove instrument panel
SeeINSTRUMENTS,
Repair, instrument panel
.
5. Release heatercableatcontrol lever
See
HEATING ANDVENTILATION, Repair,Heater
control cable-air distribution
.
6. Remove 2screws, withdraw switchpanelfrom
lower fascia...