Land Rover Range Rover 2002my On Workshop Procedures Lm 6th Edition Nas Rover Manual

GENERAL DATA
04-16
Wheels and tyres
WARNING: The following precautions must be observed when using the space saver spare wheel:
lThe space saver spare wheel is for temporary use only, it must be replaced with the repaired standard 
wheel as soon as possible.
lOnly one space saver is to be used on the vehicle at any one time with a maximum speed of 50 mph (80 
km/h) being observed.
lThe inflation pressure of the space saver tyre must be maintained at 4.2 bar (60 lbf.in2).
lThe use of snow chains is not...

GENERAL DATA
04-17
Air conditioning
Type CFC free, sealed closed loop
Compressor:
⇒ Displacement 177.7 cm
3/rev (10.84 in3/rev)
⇒ Relief valve operating pressure 34.3 to 41.4 bar (497 to 600 lbf.in
2)
⇒ Refrigerant oil quantity 110 cc (3.8 fl.ozs)
⇒ Refrigerant oil Nippon Denso ND-8
⇒ Refrigerant HFC - R134A
⇒ Refrigerant charge quantity 510 ± 10 grammes (17.8 ± 0.8 ozs)
Oil quantities lost when changing individual 
components:
⇒ Condenser/receiver drier
⇒ Evaporator
⇒ Pipe/hose30 ml
20 ml
10 ml 

GENERAL DATA
04-18
Electrical - Td6
Electrical - V8
System 12 volt, negative earth
Battery:
⇒ Type 12 volt
⇒ Capacity 110 amp hour
Alternator:
⇒ Type Valeo A14V, air cooled
⇒ Maximum output 150 amp
Starter motor:
⇒ Type Nippon Denso, E95 RL
⇒ Power 2.2 kW
System 12 volt, negative earth
Battery:
⇒ Type 12 volt
⇒ Capacity 110 amp hour
Alternator:
⇒ Type Bosch KF, water cooled
⇒ Maximum output 150 amp
Starter motor
⇒ Type Nippon Denso, 112V RA
⇒ Power 1.8 kW 

GENERAL DATA
04-19
Dimensions
* Measurement taken with vehicle at unladen weight.
Weights
CAUTION: Axle weights are non additive. The individual maximum weights and gross vehicle weight must 
not be exceeded.
Overall length  4950 mm (193.1 in)
Overall width (including mirrors) 2191 mm (85.4 in)
Overall width (mirrors folded) 2009 mm (78.4 in)
Overall height *:
⇒ Access
⇒ Motorway
⇒ Standard
⇒ Off road1820 mm (71.1 in)
1840 mm (71.7 in)
1863 mm (73.1 in)
1913 mm (74.6 in)
Minimum ground clearance - Off...

GENERAL DATA
04-20 

IDENTIFICATION NUMBERS
05-1
IDE NTIFICATION NUMBERS
Vehicle Identification Number
Location
The Vehicle Identification Number (VIN) plate is on a 
label; attached to the inner wing, in front of the LH 
suspension turret. The VIN is also stamped in the 
following locations:
lOn a plate behind the LH lower corner of the 
windscreen.
lOn the front of the RH suspension turret.
RH Suspension turret VIN
Windscreen VINInner wing VIN
On NAS, Canadian and Gulf models, the inner wing 
VIN plate is replaced by a...

IDENTIFICATION NUMBERS
05-2
VIN plate content
The VIN plate contains the following information:
aModel name
bEngine description
cCountry text
dDiesel indicator
eColour code/group
fReserved
gHeadlight code
hLand Rover
iEU type approval
jVehicle Identification Number (VIN)
kTotal weight
lTowing weight
mFront axle weight
nRear axle weight
oExterior paint stickerVehicle identification number - except NAS and 
Canada
Example: SALLMAMA41A001099
Vehicle identification number - NAS and Canada
Example:...

IDENTIFICATION NUMBERS
05-3
Identification Number Locations
Engine number
Td6 Engine
The Td6 engine serial number is stamped on the LH 
side of the cylinder block
V8 Engine
The V8 engine serial number is stamped on the top 
of the cylinder block at the front of the engine, 
beneath the throttle housing.Td6 automatic gearbox number
The GM automatic gearbox serial number is on a 
plate attached to the LH side of the gearbox.
V8 automatic gearbox number 
The ZF automatic gearbox serial number is on a 
plate...

IDENTIFICATION NUMBERS
05-4
Transfer box number
The New Venture Gears transfer box serial number 
is etched on a boss located at the rear of the unit 
above the oil drain plug.Paint code - NAS, Canadian and Gulf markets 
only
The vehicle paint colour is shown on the LH inner 
wing.
NOTE: Only the paint colour is shown, and not the 
paint code.
M01 0318 

TORQUE WRENCH SETTINGS
06-1
TORQUE WRE NCH SETTINGS
Maintenance
TORQUE DESCRIPTION METRIC IMPERIAL
Spark plugs31 Nm 23 lbf.ft
Td6 oil sump drain plug 23 Nm 17 lbf.ft
Td6 oil filter cap 25 Nm 18 lbf.ft
V8 oil sump drain plug 17 Nm 13 lbf.ft
V8 oil filter cap 25 Nm 18 lbf.ft
Td6 (GM) Automatic gearbox oil filler/level plug 20 Nm 15 lbf.ft
V8 (ZF) Automatic gearbox oil filler/level plug 35 Nm 26 lbf.ft
Road wheel nuts  140 Nm 103 lbf.ft