Home > Ford > Automobile > Ford F 750 Owners Manual

Ford F 750 Owners Manual

    Download as PDF Print this page Share this page

    Have a look at the manual Ford F 750 Owners Manual online for free. It’s possible to download the document as PDF or print. UserManuals.tech offer 41 Ford manuals and user’s guides for free. Share the user manual or guide on Facebook, Twitter or Google+.

    							CAPACITIES AND SPECIFICATIONS - 6.8L
    Capacities
    WARNING
    The air conditioning refrigerant system contains refrigerant under high pressure.
    Only qualified personnel should service the air conditioning refrigerant system.
    Opening the air conditioning refrigerant system can cause personal injury.
    Capacity
    Item
    7.0 qt (6.6 L)
    Engine oil (with oil filter)
    28.8 qt (27.3 L)1
    Engine coolant
    58 gal (219.5 L)
    Fuel tank (Limited Series)
    (Usable capacity)2
    62 gal (234.6 L)
    (Liquid capacity)
    47 gal (177.9 L)
    Fuel tank (Small)
    (Usable capacity)2
    50 gal (189.2 L)
    (Liquid capacity)
    59 gal (223.3 L)
    Fuel tank (Large)
    (Usable capacity)2
    63 gal (238.4 L)
    (Liquid capacity)
    Between MIN and MAX on brake fluid reservoir
    Brake fluid
    17.4 qt (16.5 L)3
    Automatic transmission fluid
    6–7 fl oz (177 –207 ml)
    Front axle wheel bearing oil (8500 lb axle)
    12–13 fl oz (355– 385 ml)
    Front axle wheel bearing oil (all except
    8500 lb axle)
    19 pt (9.0 L)4
    Rear axle (S-140)(13.5k, 17.5k, 19k single
    speed)
    37 pt (17.5 L)4
    Rear axle (S-170)(23k single speed)
    258
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Capacity
    Item
    37 pt (17.5 L)4
    Rear axle (S-190)(26k single speed)
    28 pt (13.2 L)4
    Rear axle (21060S)(21k single speed)
    5.2 qt (4.9 L)4
    Power Steering (air brake equipped)
    6.1 qt (5.8 L)4
    Power Steering (hydraulic brake equipped)
    Fill as required
    Windshield washer fluid
    29.1 oz (0.825 kg)
    A/C refrigerant
    7.1 fl oz (210 ml)5
    A/C refrigerant compressor oil
    1 Use the coolant type originally equipped in your vehicle. Using any other coolant may
    result in vehicle damage.
    2 Do NOT fill above the 95% liquid capacity.
    3 Approximate dry fill capacity. Actual amount may vary during fluid changes.
    4 Capacities may be higher if the vehicle is equipped with a cooler. Always check to make
    sure the fluid level is in the acceptable range.
    5 This system uses mineral-based refrigerant oil to lubricate O-rings and fittings.
    Specifications
    Materials Specification
    Name
    WSS-M2C945-A
    Recommended motor oil (U.S. and Mexico):
    Motorcraft® SAE 5W-20 Premium Synthetic Blend Motor
    Oil
    XO-5W20-QSP
    WSS-M2C945-A
    Recommended motor oil (Canada):
    Motorcraft® SAE 5W-20 Super Premium Motor Oil
    CXO-5W20-LSP12
    WSS-M2C945-A
    Optional motor oil (U.S. and Mexico):
    Motorcraft® SAE 5W-20 Full Synthetic Motor Oil
    XO-5W20-QFS
    WSS-M2C945-A
    Optional Motor oil (Canada):
    Motorcraft® SAE 5W-20 Synthetic Motor Oil
    CXO-5W20-LFS12
    259
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Specification
    Name
    WSS-M97B44-D2
    Engine coolant (U.S. and Mexico):
    Motorcraft® Orange Prediluted Antifreeze/Coolant
    VC-3DIL-B
    WSS-M97B44-D2
    Engine coolant (Canada):
    Motorcraft® Orange Prediluted Antifreeze/Coolant
    CVC-3DIL-B
    WSS-M6C65-A3
    Brake fluid:
    Motorcraft® DOT 5.1 Motor Vehicle Brake Fluid
    PM-21
    WSS-M2C938-A
    Automatic transmission fluid (U.S. and Mexico):
    MERCON LV
    Motorcraft® MERCON LV Automatic Transmission Fluid
    XT-10-QLVC
    WSS-M2C938-A
    Automatic transmission fluid (Canada):
    MERCON LV
    Motorcraft® MERCON LV Automatic Transmission Fluid
    CXT-10-QLVC
    WSL-M2C192-A
    Front axle (wheel bearing oil):
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSP-M2C197-A1
    Recommended Rear axle fluid (U.S. and Mexico): (S-
    140)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A1
    Recommended Rear axle fluid (Canada): (S-140)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    CXY-80W90-1L
    WSL-M2C192-A1
    Optional Rear axle fluid (U.S. and Mexico): (S-140)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSL-M2C192-A1
    Optional Rear axle fluid (Canada): (S-140)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    CXY-75W140-1L
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S. and Mexico): (S-170)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (Canada): (S-170)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    CXY-80W90-1L
    260
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Specification
    Name
    WSL-M2C192-A
    Optional Rear axle fluid (U.S. and Mexico): (S-170)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSL-M2C192-A
    Optional Rear axle fluid (Canada): (S-170)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    CXY-75W140-1L
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S. and Mexico): (S-
    190)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (Canada): (S-190)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    CXY-80W90-1L
    WSL-M2C192-A
    Optional Rear axle fluid (U.S. and Mexico): (S-190)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSL-M2C192-A
    Optional Rear axle fluid (Canada): (S-190)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    CXY-75W140-1L
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S.): (21060S)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (Canada): (21060S)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    CXY-80W90-1L
    WSL-M2C192-A
    Optional Rear axle fluid (U.S.): (21060S)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSL-M2C192-A
    Optional Rear axle fluid (Canada): (21060S)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    CXY-75W140-1L
    WSS-M2C938-A
    Power steering fluid:
    MERCON LV
    Motorcraft® MERCON LV
    XT-10-QLVC
    WSB-M8B16-A2
    Windshield washer fluid (U.S. and Mexico):
    Motorcraft® Premium Windshield Wash Concentrate
    with Bitterant
    ZC-32-B2
    261
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Specification
    Name
    WSB-M8B16-A2
    Windshield washer fluid (Canada):
    Motorcraft® Premium Quality Windshield Washer Fluid
    CXC-37-(A, B, D, F)
    WSH-M17B19-A
    A/C refrigerant (U.S.):
    Motorcraft® R-134a Refrigerant
    YN-19
    WSH-M17B19-A
    A/C refrigerant (Canada):
    Motorcraft® R-134a Refrigerant
    CYN-16-R
    WSH-M17B19-A
    A/C refrigerant (Mexico):
    Motorcraft® R-134a Refrigerant
    MYN-19
    WSH-M1C231-B
    A/C refrigerant compressor oil:
    Motorcraft® PAG Refrigerant Compressor Oil
    YN-12-D
    ESB-M1C93-B
    Multi-purpose grease:
    Motorcraft® Multi-Purpose Grease Spray
    XL-5-A
    --
    Lock cylinders (U.S.):
    Penetrating and Lock Lubricant
    XL-1
    --
    Lock cylinders (Canada):
    Penetrating Fluid
    CXC-51-A
    --
    Lock cylinders (Mexico):
    Penetrating and Lock Lubricant
    MXL-1
    WSD-M1C227-A
    Transmission, parking brake linkages and pivots, brake
    pedal shift:
    Motorcraft® Premium Long-Life Grease
    XG-1-E1
    1 Motorcraft® SAE 75W-140 Synthetic Rear
    Axle Lubricant is standard for (Limited
    Series) vehicles. If you use oil and fluids that do not meet
    the defined specification and viscosity
    grade, this may lead to:
    •
    Component damage which is not
    covered by the vehicle warranty.
    • Longer engine cranking periods.
    262
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							•
    Increased emission levels.
    • Reduced engine performance.
    • Reduced fuel economy.
    • Degraded brake performance.
    We recommend Motorcraft® motor oil for
    your vehicle. If Motorcraft® oil is not
    available, use motor oils of the
    recommended viscosity grade that meet
    API SN requirements and display the API
    Certification Mark for gasoline engines. Do
    not use oil labeled with API SN service
    category unless the label also displays the
    API certification mark. An oil that displays this symbol conforms
    to current engine, emission system and
    fuel economy performance standards of
    the International Lubricants Specification
    Advisory Committee (ILSAC).
    Do not use supplemental engine oil
    additives because they are unnecessary
    and could lead to engine damage that may
    not be covered by your vehicle warranty.
    Note:
    Ford recommends using DOT 4 Low
    Viscosity (LV) High Performance Brake Fluid
    or equivalent meeting WSS-M6C65-A2. Use
    of any fluid other than the recommended
    fluid may cause degraded brake
    performance and not meet the Ford
    performance standards. Keep brake fluid
    clean and dry. Contamination with dirt,
    water, petroleum products or other
    materials may result in brake system
    damage and possible failure.
    Note:  Automatic transmissions that require
    MERCON LV transmission fluid should only
    use MERCON LV transmission fluid.  The
    use of any other fluid may cause
    transmission damage.
    CAPACITIES AND SPECIFICATIONS - 6.7L DIESEL
    Capacities WARNING
    The air conditioning refrigerant system contains refrigerant under high pressure.
    Only qualified personnel should service the air conditioning refrigerant system.
    Opening the air conditioning refrigerant system can cause personal injury.
    Capacity
    Item
    15.0 qt (14.2 L)
    Engine oil (with oil filter)
    35.1 qt (33.2 L)1
    Engine coolant (primary high-temperature
    cooling system loop)
    48 fl oz (1.41 L)2
    Engine coolant additive (primary high-
    temperature cooling system loop)
    263
    F-650/750 (TBC) , enUSA, First Printing Capacities and SpecificationsE142732  
    						
    							Capacity
    Item
    15.1 qt (14.3 L)1
    Engine coolant (secondary cooling system)
    16.0 fl oz (473 ml)2
    Engine coolant additive (secondary cooling
    system)
    8 gal (30.2 L)
    Diesel Exhaust Fluid (DEF)
    61 gal (230.9 L)
    Fuel tank (Dual)(Left side)
    (Usable capacity)3
    65 gal (246 L)
    (Liquid capacity)
    47 gal (177.9 L)
    Fuel tank (Dual)(Right side)
    (Usable capacity)3
    50 gal (189.2 L)
    (Liquid capacity)
    47 gal (177.9 L)
    Fuel tank (Small)
    (Usable capacity)3
    50 gal (189.2 L)
    (Liquid capacity)
    53 gal (200.6 L)
    Fuel tank (Medium)
    (Usable capacity)3
    56 gal (211.9 L)
    (Liquid capacity)
    61 gal (230.9 L)
    Fuel tank (Large)
    (Usable capacity)3
    65 gal (246 L)
    (Liquid capacity)
    Between MIN and MAX on brake fluid reservoir
    Brake Fluid
    16.3 qt (15.4 L)4
    Automatic Transmission Fluid
    6–7 fl oz (177 –207 ml)
    Front axle wheel bearing oil (8500 lb axle)
    12–13 fl oz (355– 385 ml)
    Front axle wheel bearing oil (all except
    8500 lb axle)
    264
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Capacity
    Item
    19 pt (9.0 L)4
    Rear axle (S-140)(13.5k, 17.5k, 19k single
    speed)
    37 pt (17.5 L)4
    Rear axle (S-170)(23k single speed)
    37 pt (17.5 L)4
    Rear axle (S-190)(26k single speed)
    28 pt (13.2 L)4
    Rear axle (21060S)(21k single speed)
    35 pt (16.6 L)4
    Rear axle (21065T/P)(21k two speed)
    5.2 qt (4.9 L)5
    Power Steering (air brake equipped)
    6.1 qt (5.8 L)5
    Power Steering (hydraulic brake equipped)
    Fill as required
    Windshield washer fluid
    26.5 oz (0.75 kg)
    A/C refrigerant
    5.1 fl oz (150 ml)6
    A/C refrigerant compressor oil
    1 Use the coolant type originally equipped in your vehicle. Using any other coolant may
    result in vehicle damage.
    2 Per addition if required.
    3 Do NOT fill above the 95% liquid capacity.
    4 Approximate dry fill capacity. Actual amount may vary during fluid changes.
    5 Capacities may be higher if the vehicle is equipped with a cooler. Always check to make
    sure the fluid level is in the acceptable range.
    6 This system uses mineral-based refrigerant oil to lubricate O-rings and fittings.
    265
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Specifications
    Materials
    Specification
    Name
    WSS-M2C171-E*
    Recommended motor oil (U.S.):
    Motorcraft® SAE 10W-30 Super Duty Diesel Motor Oil
    XO-10W30-QSD
    WSS-M2C171-E*
    Recommended motor oil (Canada):
    Motorcraft® SAE 10W-30 Super Duty Diesel Motor Oil
    CXO-10W30-LSD12
    WSS-M2C171-E*
    Recommended motor oil (U.S.):
    Motorcraft® SAE 15W-40 Super Duty Diesel Motor Oil
    XO-15W40-QSD
    WSS-M2C171-E*
    Recommended motor oil (Canada):
    Motorcraft® SAE 15W-40 Super Duty Diesel Motor Oil
    CXO-15W40-LSD12
    WSS-M2C171-E*
    Recommended motor oil (U.S.):
    Motorcraft® SAE 5W-40 Full Synthetic Diesel Motor Oil
    XO-5W40-5QSD
    WSS-M2C171-E*
    Recommended motor oil (U.S.):
    Motorcraft® SAE 0W-40 Full Synthetic Diesel Motor Oil
    XO-0W40-DAS
    WSS-M97B44-D2
    Engine and secondary cooling system coolant (U.S.):
    Motorcraft® Orange Prediluted Antifreeze/Coolant
    VC-3DIL-B
    WSS-M97B44-D2
    Engine and secondary cooling system coolant (Canada):
    Motorcraft® Orange Prediluted Antifreeze/Coolant
    CVC-3DIL-B
    --
    Engine and secondary cooling system coolant additive:
    Motorcraft® Specialty Orange Engine Coolant Revitalizer
    VC-12
    WSS-M99C130-A
    Diesel Exhaust Fluid (DEF):
    Motorcraft® Diesel Exhaust Fluid
    PM-27-Gal / PM-27-Jug
    --
    Cetane Booster & Performance Improver (U.S.):
    Motorcraft® Cetane Booster & Performance Improver
    PM-22-A
    --
    Cetane Booster & Performance Improver (Canada):
    266
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    							Specification
    Name
    Motorcraft® Cetane Booster & Performance Improver
    PM-22-B --
    Anti-Gel & Performance Improver (U.S.):
    Motorcraft® Anti-Gel & Performance Improver
    PM-23-A
    --
    Anti-Gel & Performance Improver (Canada):
    Motorcraft® Anti-Gel & Performance Improver
    PM-23-B
    WSS-M6C65-A3
    Brake fluid:
    Motorcraft® DOT 5.1 Motor Vehicle Brake Fluid
    PM-21
    WSS-M2C938-A
    Automatic transmission fluid (U.S. and Mexico):
    MERCON LV
    Motorcraft® MERCON LV Automatic Transmission Fluid
    XT-10-QLVC
    WSS-M2C938-A
    Automatic transmission fluid (Canada):
    MERCON LV
    Motorcraft® MERCON LV Automatic Transmission Fluid
    CXT-10-QLVC
    WSL-M2C192-A
    Front axle (wheel bearing oil):
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S.): (S-140)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (Canada): (S-140)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    CXY-80W90-1L
    WSL-M2C192-A
    Optional Rear axle fluid (U.S.): (S-140)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    XY-75W140-QL
    WSL-M2C192-A
    Optional Rear axle fluid (Canada): (S-140)
    Motorcraft® SAE 75W-140 Synthetic Rear Axle Lubricant
    CXY-75W140-1L
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S.): (S-170)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    XY-80W90-QL
    WSP-M2C197-A
    Recommended Rear axle fluid (U.S.): (S-170)
    Motorcraft® SAE 80W-90 Premium Rear Axle Lubricant
    267
    F-650/750 (TBC) , enUSA, First Printing Capacities and Specifications 
    						
    All Ford manuals Comments (0)

    Related Manuals for Ford F 750 Owners Manual