Konica Minolta magicolor 2590MF User Manual

Replacing the Toner Cartridge 127
When replacing a toner cartridge, refer to the following table. For optimum 
print quality and performance, use only approved KONICA MINOLTA toner 
cartridges for your specific machine type, as listed in the table below. If you 
open the engine cover, you can find your machine type and the toner car-
tridge part numbers on the consumables reorder label inside your machine.
Machine 
Ty p eMachine 
Part NumberToner Cartridge Type Toner Cartridge 
Part Number
AM 5250225-100...

Replacing the Toner Cartridge 128
Keep toner cartridges: 
„In their packaging until you’re ready to install them.
„In a cool, dry location away from sunlight (due to heat). 
The maximum storage temperature is 35° C (95° F) and the maximum 
storage humidity is 85% (noncondensing). If the toner cartridge is moved 
from a cold place to a warm, humid place, condensation may occur, 
degrading print quality. Allow the toner to adapt to the environment for 
about one hour before use.
„Level during handling and...

Replacing the Toner Cartridge 129 To Replace a Toner Cartridge
Note
Be careful not to spill toner while replacing a toner cartridge. If toner 
spills, immediately wipe it off with a soft, dry cloth.
When a toner cartridge becomes empty, the messages 
X TONER EMPTY 
and 
CHANGE X TONER (X indicates the toner color) alternately appear. Fol-
low the procedure described below to replace the toner cartridge.
1Check the display to see which color of toner is empty.
As an example, the procedure for replacing...

Replacing the Toner Cartridge 130
The scanner unit cannot 
be released if the ADF 
has been opened. Be 
sure to gently close the 
ADF first, then release 
the scanner unit.
4Open the scanner unit.
Be careful not to touch 
the plate on the back of 
the scanner unit.
Downloaded From ManualsPrinter.com Manuals 

Replacing the Toner Cartridge 131
5Pull the lever, and then open the 
engine cover.
Do not touch the transfer 
belt.
If there is media in the 
output bin, remove it.
Before opening the 
engine cover, be sure to 
fold up the output bin.
Downloaded From ManualsPrinter.com Manuals 

Replacing the Toner Cartridge 132
6Open the front cover and check 
that the toner cartridge to be 
replaced has rotated to the 
exchange position.
You can identify the toner 
cartridge by the color of 
the handle and by the let-
ter molded into the han-
dle: C (cyan), M 
(magenta), Y (yellow) 
and K (black).
7Pull the handle on the toner car-
tridge toward you, and then pull 
the toner cartridge up to remove 
it.
Do not manually rotate 
the toner cartridge carou-
sel. In addition, do not 
rotate the...

Replacing the Toner Cartridge 133
9Shake the cartridge a few times 
to distribute the toner.
Make sure that the toner 
roller cover is securely 
attached before shaking 
the toner cartridge.
10Remove the cover from the 
toner roller.
Do not touch or scratch 
the toner roller.
11Align the shaft on each end of 
the toner cartridge with its hold-
ers, and then insert the car-
tridge.
Before inserting the toner 
cartridge, make sure that 
the color of the toner car-
tridge to be installed is 
the same as...

Replacing the Toner Cartridge 134
12Press down on the toner car-
tridge until it snaps into place.
13Close the front cover.
Before closing the engine 
cover, be sure to close 
the front cover. The front 
cover cannot be closed 
after the engine cover is 
closed.
14Carefully close the engine cover.
Downloaded From ManualsPrinter.com Manuals 

Replacing the Toner Cartridge 135
15Carefully close the scanner unit.
When the scanner unit is 
closed, the black toner 
cartridge automatically 
moves so that it can be 
replaced. With each 
press of the TC Change 
key, the yellow, then 
magenta toner cartridge 
moves so that it can be 
replaced.
16Press the Stop/Reset key.
The message is erased from the message window, and machine is reset 
so that it can continue printing.
If no operation is performed for more than 30 seconds after the 
scanner unit...

Replacing the drum cartridge 136
Replacing the drum cartridge
When the drum cartridge reaches the end of its service life, the messages 
DRUM LIFE END and CHANGE DRUM alternately appear. Follow the pro-
cedure described below to replace the drum cartridge.
1Pull the scanner unit release 
lever.
The scanner unit cannot 
be released if the ADF 
has been opened. Be 
sure to gently close the 
ADF first, then release 
the scanner unit.
Downloaded From ManualsPrinter.com Manuals