Honda Bmw 5 Service Manual

Door Windows 
molding and 
anti-trap  strip 
4 If replacing  molding with  new  one, transfer mounting clips 
and  foam insulation as  necessary. 
1. Window frame  molding 
2. Clip 
3. Door corner  speaker cover 
4. Foam insulation 
- After  installation, recheck anti-trap protection. 
Rear window anti-trap  strip, removing 
- Remove rear door  panel and vapor barrier as described  in 
411 Doors. 
4 Remove window frame  molding  strip, peeling  it off  fixed  win- 
dow  partition 
(arrows). Do not  tear...

51 2-8 
Door Windows 
Door window,  adjusting 
Whenever the door window  or window  regulator is removed, 
window  adjustment should be  checked. The glass should 
contact the top  of the  window  squarely and should  seat 
against the  window seal uniformly. 
NOTE- 
If the  window  does not contact  the  window  seal uniformly, 
wind noise  or water  infiltration  may result. 
- Remove door  panel as described in 411 Doors. 
- Disconnect negative (-) cable from  battery. Remove airbag 
unit  and vapor...

512-9 
Door Windows 
Vertical adjustment 
- Adjustments  are made with  window in open position 
4 Loosen window  clamping fasteners  (arrows),  but do not 
remove. 
Adjust  rear  clamp and tighten  fastener. 
Tighten  front clamp  fastener. 
4 Raise door window  up to stop: 
Check gap  (A) at window front  edge, 
Checlc gap (5) at window  top edge. 
NOJE- 
Measure  window frame  between door window  edge and 
panel. 
Front window  gap settings 
Front  of window 
(A) 5.4 mm (0.21  in) 
Top  of window...

Door Windows 
Worlting carefully  with a plastic prying tool,  remove window 
trim  strip  from door. 
Starting  from  rear  of inner  window  trim strip, carefully 
on  trim  strip  clips 
(arrows) to  remove window trim. 
< Loosen 1 clamping  jaw  fasteners (arrows)   

Door Windows 
Tilt window glass carefully  inside door  cavity and lift out  of 
door. 
Installation is  reverse  of removal. 
Replace  plastic window retainers once glass  is inside  door. 
Use  new  mounting  bolts when reinstalling side-impact 
air- 
bag to door. 
Adjust  window  as described  earlier, 
Sedan  and Sport  Wagon  doors are similar.  There are two  win- 
dow  rails in each  front window regulator,  only one in the rear. 
Otherwise  the front  and  rear  regulators are similar. 
WARNING-...

512-12 
I Door Windows 
- Disconnect window from window  guide rail as described  in 
Door  window,  removing 
and installing.  Do not  remove 
window  from door. 
* Push  window  up and  use wedge  to hold  in position. 
- If necessary,  remove speaker  unit  from door. 
- Removing  window regulator from  door: 
Disconnect  window motor electrical  harness connector. 
4 Remove  lower window  regulator fasteners  (arrows). 
Remove  window  regulator  fasteners (arrows) 
Loosen  fasteners  (arrows) and...

Door windows1 
Rear window  regulator,  removing and 
installing 
NOTE- 
BMW recommends removing  the  window regulator and mo- 
tor  as one  unit,  then separating  the 
two on the bench. 
- Disconnect negative (-) cable  from battery 
- Remove door  panel as described  in 411 Doors 
- Remove airbag unit and  vapor  barrier  from door.  See 721 
Airbag System  (SRS). 
- Disconnect  window from window  guide rail  as described  in 
Door  window,  removing  and installing.  Do not remove 
window  from...

513-1 
51 3 lnterior Trim 
General . . . . . . . . . . . . . . . . . . . . . . . . . . . ,513-2 
Interior trim repairs . . . . . . . . . . . . . . . . . . . ,513-2 
Center Console . . . . . . . . . . . . . . . . . . . . .513-3 
Center console, removing and installing . . . 213-3 
Dash Panel . . . . . . . . . . . . . . . . . . . . . . . . ,513-7 
Lower dash panel  assembly, 
removing and installing 
. . . . . . . . . . . . . . . . ,513-7 
Upper dash assembly, 
removing and installing 
. . . . . . . . . ....

I lnterior Trim 
This repair group  covers interior trim  removal and installation 
procedures. 
- Refer  to the  following  repair groups  for additional  information: 
250 Gearshift Linkage 
41 1 Doors (interior door panels) 
@ 612 Switches 
620 Instruments 
640 Heating and  Air Conditioning [IHKA control  panel! 
650 Radio 
721 Airbag System  (SRS) 
lnterior trim repairs 
lnterior trim  and finish  panels are clipped  or screwed into 
place.  Many of the trim  retaining clips are designed 
to be used...