Brother Hl 4200cn User Manual

PAPER JAMS   6 - 6
Paper Jams Between the Print Head Cartridge and the 
Fuser Unit
This section describes the procedures to remove paper jammed around the print head cartridge and in 
the fuser. Select the appropriate procedure according to the location of the jammed paper.
Paper jams around the print head cartridge
Follow the procedure below to remove the jammed paper.
1Push up button A (1) and fully open the front cover 
(2).
2If there is paper jammed around the print head 
cartridge (Illustration A),...

6 - 7   PAPER JAMS
3Open the fuser unit levers and remove the jammed 
paper. 
If the paper is torn, remove any scraps of paper 
remaining inside the printer.
4Be sure to close the fuser unit levers after removing 
the jammed paper.
5Close the front cover.
 

PAPER JAMS   6 - 8
Paper jams around the fuser unit
Follow the procedure below to remove the jammed paper.
1Push up button B (1) and fully open the front cover 
(2).
2Open the levers at the ends of the fuser unit and 
remove the jammed paper.
If the paper is torn, remove any scraps of paper 
remaining inside the printer.
During operation, the fuser unit (heater) becomes 
very hot. To prevent burns, do not touch it with your 
bare hands.
3Be sure to close the levers at the ends of the fuser 
unit after...

6 - 9   PAPER JAMS
Paper longer than 360 mm (14 in.) jams
If paper longer than 355.6 mm (14 in.) jams in the printer, cut the paper as necessary and remove the 
paper from the location where it is jammed using the appropriate procedure. If the front cover is difficult 
to open, do not force it. Turn the printer off immediately and contact your dealer or Brother Customer 
Service.
Paper Jams in the Paper Rotator
Follow the procedure below to remove the jammed paper.
1Push in button B (1) and fully open...

PAPER JAMS   6 - 10
Paper Jams in the 2 Tray Module
Follow the procedure below to remove the jammed paper.
1Starting with the bottom tray, pull out each tray until 
you find the jammed paper.
Paper in the tray module feeds to the printer from 
the front of the trays, therefore paper jammed in the 
lower tray can block the upper tray of the module or 
the paper tray in the printer, preventing you from 
opening them. Look for the jammed paper 
sequentially, starting with the lowest tray.
2Remove all the...

6 - 11   PAPER JAMS
4Push up button A (1) and fully open the front cover 
(2). Confirm that there are no scraps of paper 
remaining inside the printer.
5Close the front cover.
6Close all open paper trays.
 

ROUTINE MAINTENANCE AND CONSUMABLE REPLACEMENT   7 - 1
7
Replacing the Toner Cartridges (TN-12BK/Y/M/C)
The printer uses four toner cartridges: black, yellow, magenta and cyan. When the toner supply in a 
cartridge begins to run out, the message Replace xxxx Toner (x) message appears on the 
operation panel (xxxx is the toner cartridge color). Replace toner cartridge(s) as soon as the message 
prompting you to do so appears. The printer will stop operating if you do not replace the toner cartridge 
when...

7 - 2   ROUTINE MAINTENANCE AND CONSUMABLE REPLACEMENT
Replacing the Toner Cartridges
Follow the procedure below to replace toner cartridges.
1Remove the top cover and place it on a flat surface.
2Grip the levers at the ends of the toner cartridge that 
you want to replace and pull them up.
 

ROUTINE MAINTENANCE AND CONSUMABLE REPLACEMENT   7 - 3
3Pull out the toner cartridge.
■Put the toner cartridge onto a piece of paper to 
prevent the toner from staining the floor or 
furniture.
■To prevent residual toner form spilling, avoid 
shaking or bumping used toner cartridges.
4Select the new toner cartridge that is being 
replaced, and remove it from its packaging.
5Shake the toner cartridge 7 or 8 times as illustrated 
to distribute toner evenly.
6Align the toner cartridge with the corresponding...

7 - 4   ROUTINE MAINTENANCE AND CONSUMABLE REPLACEMENT
7Grip the levers at each end of the toner cartridge 
with your fingers, then push down firmly to rotate the 
levers forward to the ( ) position.
8Pull the toner seal straight up to remove it.
■Pull the toner seal straight up. Pulling the toner 
seal diagonally may tear the seal.
■If it takes more than five seconds until you 
remove the toner seal after inserting the toner 
cartridge in the printer, an error message may 
appear. In this case, perform...