Panasonic Digital Imaging System For Copier Dp 6000 Operating Instructions

7-2  Paper Jams169
Troubleshooting
7
This message will not appear and
the machine will not resume its
operation if the tray is not closed
properly.  If sheets of paper are also
jammed at other locations, other
error messages will be displayed.
The following messages will be shown on the display if paper is jammed at
Tray 5 (Bypass).
Remove the jammed paper by following the procedures shown below.
Procedure
Pull out the paper tray that
is shown on the display.
Remove the jammed
paper.
Push the tray in...

7-2  Paper Jams170
Troubleshooting
7
The following messages will be shown on the display if paper is jammed at
Tray 6 (High Capacity Feeder).
Paper Jam at Tray 6 (High Capacity Feeder)
Remove other paper loaded in the
tray before clearing the paper jam.
After the jam is cleared, ÒReady to
copy.  Press Start.Ó is displayed.
Procedure
Remove the jammed
paper, which is fed
halfway, from the tray.
If the paper is torn, check that
there is no remaining pieces of
paper in the machine.
Move the center lever...

7-2  Paper Jams171
Troubleshooting
7
Follow the instructions on the screen, and Procedures A-C to remove
jammed paper.
Procedure A
Open Tray 5 (Bypass) by
the grip on the left.
Move the center Lever
towards you and pull out
the tray until it stops.
Remove the jammed
paper.
Push the tray all the way in.
Procedure B
Open the Top Cover of
Tray 6 (High Capacity
Feeder).
Top cover cannot be opened when
Tray 5 (Bypass) is open.  Close Tray
5 (Bypass) before opening the Top
Cover. 

7-2  Paper Jams172
Troubleshooting
7
Lift the jammed paper.
Close the Top Cover.
Procedure C
Pull out Tray 6 (High
Capacity Feeder).
Remove the jammed
paper.
Push Tray 6 (High
Capacity Feeder) all the
way in. 

7-2  Paper Jams173
Troubleshooting
7
The following messages will be shown on the display if paper is jammed at
the lower right section of the machine.
When these messages appear, follow the instructions in Steps 1 and 2 to
remove the jammed paper.
When these messages appear, follow the instructions from Steps 1 to 5.
Procedure
Push down on the Release
Latch on the Lower Right
Cover of the machine to
open it.
Paper Jam at Lower Right Section of the Machine 

7-2  Paper Jams174
Troubleshooting
7
Remove the jammed paper
slowly.
If the paper could not be
removed in Step 2, pull up the
Green Lever (as indicated by
the arrow on the upper right
hand side of the cover) to
open the Inner Cover.
Remove the jammed paper
slowly.
Close the Inner Cover
completely until you hear
the click sound.
Close the Lower Right Cover of the machine.
If the cover is not closed completely,
error messages will continue to be
shown on the display and the
machine will not resume its...

7-2  Paper Jams175
Troubleshooting
7
The following messages will be shown on the display if paper is jammed
inside the machine.
Follow the steps below to remove jammed paper.
Procedure
Open the Front Door.
Turn the Green Lever at
the center of the transfer
unit clockwise until it is in
the horizontal position.
Then pull the Transfer Unit
out slowly until it stops.
When pulling out the
Transfer Unit, be
careful that your
fingers are not hurt
by the pincers.
The error messages shown on the
right indicate...

7-2  Paper Jams176
Troubleshooting
7
Remove the jammed paper
on the top right of the
Transfer Unit.
If the paper cannot be removed
easily, turn Knob 5 counter-
clockwise to eject the jammed
paper.
¥Do not put your
fingers inside the
Transfer Unit. You
may get hurt.
¥Never touch a labelled
area found on or near
the fuser unit. You can
get burnt.
Remove the jammed paper
while lifting Lever 1.
If the paper cannot be removed
easily, turn Knob A counter-
clockwise to eject the jammed
paper.
Remove the jammed...

7-2  Paper Jams177
Troubleshooting
7
Push Lever 4 to the right to
open the paper guide on
the right side of the
transfer unit.
Push in the transfer unit
until it stops and turn the
Green Lever counter-
clockwise until you hear a
click sound.
          If the lever does not turn,
pull out the transfer unit
halfway and then push it in
again.
Close the Front Door.
If the door is not closed completely,
error messages will continue to be
shown on the display and the
machine will not resume its
operation. If...

7-2  Paper Jams178
Troubleshooting
7
The following messages will be shown on the display if paper is jammed at
the output area during a copy job.
When these messages appear, follow the instructions from Steps 1 to
4 to remove the jammed paper.
When these messages appear, follow the instructions in Step 1 and after
Step 5 to remove the jammed paper.
Procedure
Remove the jammed paper
by pulling it out slowly from
the Output Tray.
If it cannot be removed,
push down on the Release
Latch on the Lower Right...