Panasonic Digital Imaging System For Copier Dp 6000 Operating Instructions

8-3  Increasing the Toner Level199
Daily Care
8
The following screen will be displayed for 40 seconds and the toner level will be
adjusted during this time.
No copy job can be done during this time.
 After the toner level is adjusted, the default screen re-appears. 

8-4  Replacing the Toner Cartridge200
Daily Care
8
The Toner Cartridge contains toner that decreases each time a copy is
made.  When it is time for the Toner Cartridge to be replaced, the following
messages will be shown on the message area of the display.  In this case,
follow the instructions to replace the Toner Cartridge.
Never throw a Toner Cartridge into an open flame.  It can
cause an explosion and you can get burnt.
Use Panasonic-recommended Toner Cartridges as non-
recommended ones may affect...

8-4  Replacing the Toner Cartridge201
Daily Care
8
Hold the Orange Lever and
swing it to the left to open
the toner cartridge holder.
Turn the Toner Cartridge
counter-clockwise until you
hear a click sound.  Then
pull the cartridge toward
you.
Lift the Toner Cartridge
and remove it from the
toner cartridge holder.
Never touch a
labelled area found on
or near the fuser unit.
You can get burnt.
Gently shake the new
Toner Cartridge from left to
right.
Align the     mark on the
holder with the     mark on...

8-4  Replacing the Toner Cartridge202
Daily Care
8
Push the Toner Cartridge
in and turn it clockwise
until it stops.
Hold the Orange Lever and
swing it back to the original
position until you hear a
click sound.
Close the Front Door.
If the door is not closed completely,
error messages will be shown on the
display and the machine will not
resume its operation. 

8-5  Replacing the Drum Cartridge203
Daily Care
8
The Drum Cartridge is the photoreceptor for transferring the copy image
onto the paper.  If you see the following messages displayed, follow the
instructions below to replace the Drum Cartridge.
Never throw a Drum Cartridge into an open flame. Toner
remaining in the cartridge can cause an explosion and you
can get burnt.
Use Panasonic-recommended Drum Cartridges as non-
recommended ones may affect quality and performance of
the machine.
Procedure
Turn the...

8-5  Replacing the Drum Cartridge204
Daily Care
8
Hold the Orange Lever and
swing it to the left to open
the toner cartridge holder.
Turn the Green Lever at
the center of the transfer
unit clockwise until the
Lever is in the horizontal
position.
Slowly pull out about half
of the Drum Cartridge
while pressing the Orange
Button at the top of the
Drum Cartridge.
Never touch a labelled
area found on or near
the fuser unit. You can
get burnt.
Hold the handle at the top
and pull the Drum Cartridge
straight...

8-5  Replacing the Drum Cartridge205
Daily Care
8
Push the drum in until you
hear a click sound.
Check that the Drum Cartridge
has been set properly.
Hold the Orange Lever and
swing it back to the original
position until you hear a
click sound.
Turn the Green Lever
counter-clockwise until the
click sound is heard.
Close the Front Door.
Turn the Power Switch to
the  |  position to switch
On the power.
Check that Ready to copy is
displayed.
Do not touch the surface of the drum
as you may scratch or damage...

8-6  Replacing the Staple Cartridge206
Daily Care
8
Replacing the Staple Cartridge
When it is time to replace the Staple Cartridge, the following messages will
be shown on the display.  Follow the procedures below to replace the Staple
Cartridge.  Contact your local authorized Panasonic service representative
when ordering a new Staple Cartridge.
Use Panasonic-recommended Staple Cartridges as non-
recommended ones may affect quality and performance of
the machine.
Procedure
Check that the machine
has...

8-6  Replacing the Staple Cartridge207
Daily Care
8
While pressing the position
as indicated by the right
arrow, pull to remove the
used Staple Case.
Insert a new Staple Case
into the Staple Cartridge.
Pull to remove the tab of
the Staple Case as shown
in the diagram.
Push the Staple Cartridge
back to its original position
until you hear a click
sound.
Close the Front Door of the
Finisher.
Check that the Staple Cartridge is
inserted in the correct orientation. 

8-7  Emptying the Punch Scrap Container208
Daily Care
8
When the optional Finisher with the Puncher is installed, the following
messages will be shown on the display when the punch scrap container is
full.  Follow the steps to dispose of the scraps in the container.
Each time you pull the punch scrap container out from the machine, make
sure that all the scraps are emptied before you put the container back.
You should remove the container while the power is On.  If you switch Off
the power and empty the...