Mitel Sx 200 Ml Pabx Lightware 16 Instructions Guide

SX-200@ ML PABX 
Troubleshooting 
TM, @I - Trademark of Mt.4 Corporation. 
@Copyright 1997, Mitei Corporation. 
All rights reserved 
Printed in Canada. 
@ MlTEL@  

Troubleshooting 
NOTICE 
The information contained in this document is believed to be accurate in all re- 
spects but is not warranted by Mite1 Corporation (MITELB). The information is 
subject to change without notice and should not be construed in any way as a 
commitment by Mite1 or any of its affiliates or subsidiaries. Mite1 and its affiliates 
and subsidiaries assume no responsibility for any errors or omissions in this doc- 
ument. Revisions of this document or new editions of it may be issued to...

Troubleshooting 
FOR EMERGENCY TROUBLESHOOTING 
GO TO Table 2-l. 
March 1997 Issue 1 Revision 0  

Troubleshooting 
iv THE FOLLOWING POINTS SHOULD BE CAREFULLY NOTED AND THE 
INSTRUCTIONS HEREIN STRICTLY OBSERVED : 
. 
Handle circuit cards by the edges only, and ensure that an anti-static strap 
is used. Card damage may otherwise result. 
. 
Before replacing a card, remove the original card, check for bent or dam- 
aged connectors, inspect the backplane, and reseat the original card. 
. 
If a problem has been eliminated through the replacement of a card, tem- 
porarily re-insert the original card to...

Table of Contents 
Training Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iv 
I. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i-i 
How to Use this Document ............................. 
Reasonforlssue ..................................... .................. l-l 
.................. l-l 
2. Troubleshooting - General . . . . . . . . . . . . . . . . . . . . . . . ....

Troubleshooting 
5. Miscellaneous Troubleshooting Procedures ......................... 5-1 
MaintenanceTerminal .................................................... 5-l 
System Printers ......................................................... 
5-2 
Cabinet Printer Port ................................................... 5-2 
SUPERCONSOLE 1000 Printer Port ...................................... 
5-3 
System Fail Transfer ..................................................... 
5-4 
Recorded Announcement...

Table of Contents 
Table 3-l 3 
Table 3-l 4 
Table 3-l 5 
Table 3-l 6 
Table 3-l 7 
Table 3-l 8 
Table 3-l 9 
Table 3-20 
Table 3-21 
Table 3-22 
Table 3-23 
Table 3-24 
Table 3-25 
Table 3-26 
Table 3-27 
Table 3-28 
Table 4-l 
Table 4-2 
Table 4-3 
Table 4-4 
Table 5-l 
Table 5-2 
Table 5-3 
Table 5-4 
Table 5-5 
Table 5-6 
Table 5-7 
Table 5-8 
Table 5-9 
Table 5-l 0 
Table 5-l 1 
Table 5-l 2 
Table 5-l 3 
Table 6-l 
Table 6-2 
Table 6-3 
Table 6-4 
Table 6-5 
Table 6-6 
Table 6-7 
Table 6-8 
Table...

Troubleshooting 
- 
List of Charts 
Chart 2-l Information Gathering and Clarification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 
Figure 3-l LS/GS Trunk Jumper Locations ................................... 
3-5 
Figure 3-2 E&M Trunk Module With Universal Card ............................. 
3-7 
Figure 3-3 E&M Type 1 Trunk Testing ....................................... 
3-10 
Figure 3-4 LoopTrunkTesting 
........................................... ..3-10 
Figure 3-5 Music, Paging,...

1 Introduction 
Before troubleshooting is attempted, maintenance personnel should become very 
familiar with the PABX maintenance system. A complete description of the 
maintenance system is provided in the Genera/ /kYaintenance hformahm Practice. 
Further maintenance-related information may be found in the documents listed below: 
Table l-l Maintenance Related Practices 
9109-098-l 00-NA General Description 
9109-098-l 05NA Features Description 
9109-098-l 80-NA Engineering Information 
9109-098-200-NA...

Troubleshooting 
l-2 Issue 1 Revision 0 March 1997