2012 Na Yamaha Super Tenere Manual

haha CABLE ROUTING
2-70
1. Engine ground lead
2. Wire harness
3. ABS ECU lead
4. ABS test coupler
5. ABS test coupler lead
6. Hydraulic unit assembly
7. Coolant reservoir hose
8. Oil level switch lead
9. Sidestand switch lead
10. Fuel hose
11. Fuel pump lead
12. Fuel pump coupler
13. Rear brake light switch lead
14. Neutral switch lead
15. Rear right turn signal light lead
16. Lean angle sensor sub-wire harness/frame ground  lead
17. Tail/brake light lead
18. License plate light lead
19. Rear left turn...

haha CABLE ROUTING
2-71
Rear fender (top view)
A
B
C
D
E
E
F
G
1
1
2
2
3
4
5
6
H
I
J
12
34
6
7
4
3  

haha CABLE ROUTING
2-72
1. License plate light lead
2. Rear right turn signal light lead
3. Tail/brake light lead
4. Rear left turn signal light lead
5. Frame ground lead
6. Lean angle sensor sub-wire harness
7. ABS test coupler lead
A. Route the license plate light lead and rear right  turn signal light lead between the rib and the 
carrier support on the rear fender.
B. Route the license plate light lead and rear right  turn signal light lead to the outside of the rib on the 
rear fender.
C. Make sure...

haha CABLE ROUTING
2-73  

haha 3
PERIODIC CHECKS AND ADJUSTMENTS
PERIODIC MAINTENANCE ............................................................................ 3-1
INTRODUCTION ....................................................................................... 3-1
PERIODIC MAINTENANCE CHART FOR THE EMISSION  CONTROL SYSTEM ........................................................................\
........ 3-1
GENERAL MAINTENANCE AND LUBRICATION CHART ....................... 3-1
CHECKING THE FUEL LINE...

haha CHECKING THE BRAKE LIGHT SWITCHES......................................... 3-29
ADJUSTING THE REAR BRAKE LIGHT SWITCH ................................. 3-29
CHECKING AND LUBRICATING THE CABLES .................................... 3-30
CHECKING THE THROTTLE GRIP OPERATION ................................. 3-30
CHECKING THE SWITCHES, LIGHTS AND SIGNALS ......................... 3-31
ADJUSTING THE HEADLIGHT BEAMS ................................................. 3-31
REPLACING THE HEADLIGHT BULBS...

haha   

haha PERIODIC MAINTENANCE
3-1
EAS20450
PERIODIC MAINTENANCE
EAS20460
INTRODUCTION
This chapter includes all information necessary to perform recommended c\
hecks and adjustments. If 
followed, these preventive maintenance procedures will ensure more reliable vehicle operation, a long-
er service life and reduce the need for costly overhaul work. This information applies to vehicles already 
in service as well as to new vehicles that are being prepared for sale. All service technicians should be...

haha PERIODIC MAINTENANCE
3-2
3 *Front brake 
Check operation, fluid level, 
and for fluid leakage.
 Replace brake pads if neces-
sary. 
4 *Rear brake 
Check operation, fluid level, 
and for fluid leakage.
 Replace brake pads if neces-
sary. 
5 *Brake hoses 
Check for cracks or damage.
 Check for correct routing and 
clamping. 
 Replace. Every 4 years
6 *Wheels 
Check runout, spoke tight-
ness and for damage.
 Tighten spokes if necessary. 
7 *Tires 
Check tread depth and for 
damage.
 Replace...

haha PERIODIC MAINTENANCE
3-3
EAU38440
TIP
 Air filter
This model ’s air filter is equipped with a disposable oil-coated paper element, which must not be 
cleaned with compressed air to avoid damaging it.
 The air filter element needs to be replaced more frequently when riding in unusually wet or dusty 
areas.
 Hydraulic brake and clutch systems
After disassembling the brake or clutch master cylinders, caliper cylinders or clutch release cylinder, 
always change the fluid. Regularly check the brake...