Konica Minolta magicolor 4650EN User Manual

							Replacing
Consumables
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 128
Replacing Consumables
Note
Failure to follow instructions as outlined in this manual could result in 
voiding your warranty.
Note
If an error message (TONER OUT, TRANS.BELT END OF LIFE, etc.) 
appears, print out the configuration page, and then check the status of the 
other consumables. For details on the error messages, refer to “Error 
Messages (Warning:)” on page 207. For details on printing the 
configuration page, refer to “Printing a Configuration Page” on page 172.
About Toner Cartridges
Your printer uses four toner cartridges: black, yellow, magenta, and cyan. 
Handle the toner cartridges carefully to avoid spilling toner inside the printer 
or on yourself.
Install only new toner cartridges in your printer. If a used toner car-
tridge is installed, the indicator message will not clear and the supplies 
status in the Status Monitor will not be updated.
The toner is nontoxic. If you get toner on your skin, wash it off with 
cool water and a mild soap. If you get toner on your clothes, lightly 
dust them off as best as you can. If some toner remains on your 
clothes, use cool, not hot water, to rinse the toner off.
CAUTION
If you get toner in your eyes, wash it out immediately with cool water 
and consult a doctor. 
Refer to the following URL for recycling information. 
US: printer.konicaminolta.net/products/recycle/index.asp 
Europe: www.konicaminolta.eu/printing-solutions/more-information/
clean-planet.html
Other regions: printer.konicaminolta.com
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 129
Note
Do not use refilled toner cartridges or unapproved toner cartridges. Any 
damage to the printer or quality problems caused by a refilled toner 
cartridge or an unapproved toner cartridge will void your warranty. No 
technical support is provided to recover from these problems.
When replacing a toner cartridge, refer to the following table. For optimum 
print quality and performance, use only approved KONICA MINOLTA toner 
cartridges for your specific printer type, as listed in the table below. You can 
find your printer type and the toner cartridge part numbers on the consum-
ables reorder label inside the front cover your printer.
Printer 
Ty p ePrinter Parts 
NumberToner Cartridge Type Toner Cartridge 
Parts Number
AMA00F 011
(magicolor 4650EN)
A00F 012(magicolor 4650DN) 
Standard-Capacity Toner Cartridge -Black (K) A0DK 131
Standard-Capacity Toner Cartridge -Yellow (Y) A0DK 231
Standard-Capacity Toner Cartridge -Magenta (M) A0DK 331
Standard-Capacity Toner Cartridge -Cyan (C) A0DK 431
High-Capacity Toner Cartridge -Black (K) A0DK 132
High-Capacity Toner Cartridge -Yellow (Y) A0DK 232
High-Capacity Toner Cartridge -Magenta (M) A0DK 332
High-Capacity Toner Cartridge -Cyan (C) A0DK 432
EUA00F 021
(magicolor 4650EN)
A00F 022(magicolor 4650DN)
Standard-Capacity Toner Cartridge -Black (K) A0DK 151
Standard-Capacity Toner Cartridge -Yellow (Y) A0DK 251
Standard-Capacity Toner Cartridge -Magenta (M) A0DK 351
Standard-Capacity Toner Cartridge -Cyan (C) A0DK 451
High-Capacity Toner Cartridge -Black (K) A0DK 152
High-Capacity Toner Cartridge -Yellow (Y) A0DK 252
High-Capacity Toner Cartridge -Magenta (M) A0DK 352
High-Capacity Toner Cartridge -Cyan (C) A0DK 452
APA00F 041
(magicolor 4650EN)
A00F 042(magicolor 4650DN)
Standard-Capacity Toner Cartridge -Black (K) A0DK 191
Standard-Capacity Toner Cartridge -Yellow (Y) A0DK 291
Standard-Capacity Toner Cartridge -Magenta (M) A0DK 391
Standard-Capacity Toner Cartridge -Cyan (C) A0DK 491
High-Capacity Toner Cartridge -Black (K) A0DK 192
High-Capacity Toner Cartridge -Yellow (Y) A0DK 292
High-Capacity Toner Cartridge -Magenta (M) A0DK 392
High-Capacity Toner Cartridge -Cyan (C) A0DK 492
GCA00F 081
(magicolor 4650EN)
A00F 082(magicolor 4650DN)
Standard-Capacity Toner Cartridge -Black (K) A0DK 181
Standard-Capacity Toner Cartridge -Yellow (Y) A0DK 281
Standard-Capacity Toner Cartridge -Magenta (M) A0DK 381
Standard-Capacity Toner Cartridge -Cyan (C) A0DK 481
High-Capacity Toner Cartridge -Black (K) A0DK 182
High-Capacity Toner Cartridge -Yellow (Y) A0DK 282
High-Capacity Toner Cartridge -Magenta (M) A0DK 382
High-Capacity Toner Cartridge -Cyan (C) A0DK 482
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 130
For optimum print quality and performance, use only the corre-
sponded TYPE genuine KONICA MINOLTA toner cartridges.
Keep toner cartridges: 
„In their packaging until you’re ready to install them.
„In a cool, dry location away from sunlight (due to heat). 
The maximum storage temperature is 35°C (95°F) and the maximum 
storage humidity is 85% (noncondensing). If the toner cartridge is moved 
from a cold place to a warm, humid place, condensation may occur, 
degrading print quality. Allow the toner to adapt to the environment for 
about one hour before use.
„Level during handling and storage. 
Do not hold, stand or store cartridges on their ends or turn them upside 
down; the toner inside the cartridges may become caked or unequally 
distributed.
„Away from salty air and corrosive gases such as aerosols.
Y
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 131 Replacing a Toner Cartridge
Note
Be careful not to spill toner while replacing a toner cartridge. If toner 
spills, immediately wipe it off with a soft, dry cloth.
If 
TONER LOW on the SYS DEFAULT MENU/ENABLE WARNING is set 
to 
ON, the message TONER LOW X (where “X”. represents the color of the 
toner) appears when toner cartridge becomes near empty. Follow the steps 
below to replace the toner cartridge.
If TONER LOW on the SYS DEFAULT MENU/ENABLE WARNING 
is set to 
OFF, you are advised to replace the indicated toner cartridge 
when the message 
TONER OUT X appear.
1Open the printer’s front cover.
2Pull the front lever of the color 
toner cartridge indicated to the 
right.
The replacement procedure for 
the toner cartridge is the same 
for all colors (yellow: Y, magenta: 
M, cyan: C, and black: K).
The following instructions show 
the procedure to replace the 
toner cartridge (Y).
Y
YMCK
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 132
3Lower the lever to release the 
lock.
4Grab the handle of the toner car-
tridge to be replaced, and then 
pull out the cartridge. 
The following instructions show 
the procedure to replace the 
toner cartridge(Y).
Note
Dispose of the used toner cartridge according to your local regulations. 
Do not burn the toner cartridge.
For details, refer to “About Toner Cartridges” on page 128.
5Check the color of the new toner cartridge to be installed.
6Remove the toner cartridge from the bag.
Y
Y
Y
Y
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 133
7Shake the cartridge to distribute 
the toner.
8Make sure that the toner car-
tridge is the same color as the 
printer compartment, and then 
insert the toner cartridge into the 
printer.
9Make sure that the toner car-
tridge is securely installed, and 
then peel off the protective film.
Y
3 ×
YY
Y
Y
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 134
10Raise the front lever to its origi-
nal position.
11Pull the lever to the left to lock it 
in place.
The front lever should be 
securely returned to its 
original position; other-
wise, the front cover of 
the printer cannot be 
closed.
12Close the front cover.
Y
Y
Y
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 135 Replacing a Imaging Unit
When replacing a imaging unit, refer to the following table. For optimum print 
quality and performance, use only approved KONICA MINOLTA imaging units 
for your specific printer type, as listed in the table below. You can find your 
printer type and the imaging unit part numbers on the consumables reorder 
label inside the front cover your printer.
Note
Do not touch the OPC drum 
surface. This could lower image 
quality.
Printer 
Ty p ePrinter Parts 
NumberImaging Unit Type Imaging Unit 
Parts Number
AMA00F 011
(magicolor 4650EN)
A00F 012(magicolor 4650DN)
Imaging Unit - Black (K) A031 00F
Imaging Unit - Yellow (Y) A031 05F
Imaging Unit - Magenta (M) A031 0AF
Imaging Unit - Cyan (C) A031 0GF
EUA00F 021
(magicolor 4650EN)
A00F 022(magicolor 4650DN)
Imaging Unit - Black (K) A031 00H
Imaging Unit - Yellow (Y) A031 05H
Imaging Unit - Magenta (M) A031 0AH
Imaging Unit - Cyan (C) A031 0GH
APA00F 041
(magicolor 4650EN)
A00F 042(magicolor 4650DN)
Imaging Unit - Black (K) A031 00H
Imaging Unit - Yellow (Y) A031 05H
Imaging Unit - Magenta (M) A031 0AH
Imaging Unit - Cyan (C) A031 0GH
GCA00F 081
(magicolor 4650EN)
A00F 082(magicolor 4650DN)
Imaging Unit - Black (K) A031 00N
Imaging Unit - Yellow (Y) A031 05N
Imaging Unit - Magenta (M) A031 0AN
Imaging Unit - Cyan (C) A031 0GN
Y
P
U
S
H
Downloaded From ManualsPrinter.com Manuals 
						

							Replacing Consumables 136
If I-UNIT LOW on the SYS DEFAULT MENU/ENABLE WARNING is set 
to 
ON, the message I-UNIT LOW X (where “X”. represents the color of the 
toner) appears when a imaging unit becomes near empty. Follow the steps 
below to replace the imaging unit.
You are advised to replace the indicated imaging unit when the mes-
sage 
I-UNIT LIFE X appears.
1Check the message window to see which color imaging unit needs replac-
ing.
2Open the printer’s front cover.
3Pull the front lever of the color 
toner cartridge indicated to the 
right.
The replacement procedure for 
the imaging unit is the same for 
all colors (yellow: Y, magenta: M, 
cyan: C, and black: K).
The following instructions show 
the procedure to replace the 
toner cartridge (K).
K
YMCK
Downloaded From ManualsPrinter.com Manuals