Canon Imagerunner 2318 User Guide

Paper Drawers3-9
Routine Maintenance
3
9Change the paper size plate to 
match the new paper size.
10Gently push the paper drawer 
back into the machine until it 
clicks into place in the closed 
position.
CAUTION
When returning the paper drawer to 
its original position, be careful not to 
get your fingers caught, as this may 
result in personal injury.
Size Plate
 

Replacing the Toner3-10
Routine Maintenance
3
Replacing the Toner
When there is only a small amount of toner remaining in the machine, the following 
message blinks on the LCD display. You may continue printing, however, it is 
highly recommended that you prepare a new toner cartridge before the toner has 
completely run out.
When prints can no longer be made as toner runs out completely, the following 
display appears on the LCD display. Follow the procedure described below to help 
you replace the...

Replacing the Toner3-11
Routine Maintenance
3
CAUTION
•Keep toner out of the reach of small children. If toner is ingested, consult a 
physician immediately.
•Take care not to allow toner to come into contact with your hands or clothing. If 
toner gets onto your hands or clothing, wash it off immediately with cold water. 
Washing it off with warm water may set the toner permanently, and make it 
impossible to remove the toner stains.
IMPORTANT
•Use only toner cartridges intended for use with this...

Replacing the Toner3-12
Routine Maintenance
3
2While pressing the unlock tab on 
the grip, turn the toner cartridge 
in the direction of the arrow 
(clockwise).
3Pressing the unlock tab, pull out 
the toner cartridge.
 
 
 
Keep unlock tab down
Unlock Tab
Remove toner
 

Replacing the Toner3-13
Routine Maintenance
3
WARNING
Do not throw used toner cartridges into open flames, as they may ignite the 
toner remaining inside the cartridge, and result in burns or a fire.
IMPORTANT
If the toner is not distributed evenly inside the cartridge, the outputs may be printed 
uneven.
4Shake the new toner cartridge 
back and forth (five or six times) 
to distribute the toner evenly 
inside the cartridge.
 
 
 
Shake new toner 5times
 

Replacing the Toner3-14
Routine Maintenance
3
5Make sure that the side of the 
cartridge with the label is facing 
up, and push the new toner 
cartridge into the machine as far 
as it will go.
Support the new toner cartridge with one 
hand from underneath, while pushing it into 
the machine with the other hand.
6Hold the toner cartridge in place 
with one hand, and then remove 
the protective seal by pulling it 
straight out with the other hand.
IMPORTANT
•Pull out the seal slowly, otherwise the 
toner...

Replacing the Toner3-15
Routine Maintenance
3
7While pushing in the unlock tab, 
turn the toner cartridge in the 
direction of the arrow 
(counterclockwise).
IMPORTANT
Turn the toner cartridge fully until it locks 
into place.
8Close the front cover.
CAUTION
When closing the front cover, be 
careful not to get your fingers 
caught, as this may result in personal 
injury.
IMPORTANT
Make sure that you clean the fixing unit 
every time you replace the toner 
cartridge. (See Chapter 6, “Routine...

Replacing the Toner3-16
Routine Maintenance
3
 

CHAPTER
4-1
4Troubleshooting
This chapter describes what to do in response to paper jams in the machine, and error 
messages.
Clearing Paper Jams  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Clearing Paper Jams with On-Screen Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
When Paper Jams Occur Frequently . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3...

Clearing Paper Jams4-2
Troubleshooting
4
Clearing Paper Jams
Clearing Paper Jams with On-Screen Instructions
If a paper jam occurs, the display below appears. It is the first page of the 
On-Screen Instructions that help you clear the paper jam. The On-Screen 
Instructions show you how to clear the paper jam step by step. You can proceed to 
the next step by pressing [ ] or return to the previous step by pressing [ ].
For more information, see Chapter 7, “Troubleshooting,” in the Reference Guide....