Yamaha Fz 09 2014 Manual

5. Meas ure: 
• Engine o il p ressure 
(a t the 
following co nd iti ons) 
Oil pressure 
230.0  kPa/5000  r/ min @100  °C 
(2.3  kgf/cm2tsooo r/min,  33.4 
psi/5000 r/min@ 212 °F) 
Out of specificati on ~ C heck. 
Engine o il pressure Po ssible causes 
•  Faulty  oil pump 
• C logged  oil fil t e r 
Be low 
spec if icat ion • Leaking oil pas -
sage 
• B ro ke n  or  dam -
age d 
oil sea l 
• 
Leak ing o il pas -
sage 
Above  specifica tio n 
•  Faulty  oil fi lter 
•  O il viscosity  too 
h ig h 
6....

1 
3 
CHANGING THE COOLANT 
1. Remove : 
• Radiato r cap bo lt  1 
• 
Rad iator  cap 2 
• 
Rad iato r cap  stoppe r 3 
EWAIOO:)) 
AwARNING 
A hot radiator  is under pressure.  Therefore , 
do not remove the radiator cap when  the en­
gine is hot. Scalding hot fluid and  steam  may 
be 
blown out, which could cause serious in­
jury.  When 
the engine  has cooled, open the 
radiat or  cap  as 
follows: 
Place 
a thick rag or a towel ove r  the  radiator 
cap and slowly turn  the radiator cap counter­...

• Coolant reservo ir 
•  Coolant reservo ir  cover 
•  Coolant reservo ir bolts 
9.  Fill: 
Coolant reservoir bolt (MS) 
0.5 Nm (0.05  m·kgf,  0.3 7 ft·lbf) 
Coolant 
reservoir bolt (M6) 
9  Nm 
(0 .

9  m·kgf , 
6.5 ft·lbf) 
•  Cooling 
system 
(with  the spec i
fied amount  of the recom ­
mended coolant) 
Recommended  antifreeze 
High-quality ethylene glycol anti­
freeze containing  corrosion 
inhibitors for aluminum engines 
Mixing  ratio 
1 
:1 (antifreeze:  water) 
Radiator  capacity 
(including...

TTTTTTTTTTTTTTTTTTTTTTTTTTTTTTTT 
a. Hold t h e  main  body 1 of the  rear brake lig ht 
swi

tch  so  th a t it d oes  not  ro tate  and  tum 
the 
ad jus ting  nut 
2 in  direc tion a o r b  un til th e 
r e a r b ra k e 
lig ht comes  on  at  th e  proper  time. 
Dire c
tion a  
Brake light come s on so oner. 
Dir ec
tion b  
Brake light com es  on la ter. 
EA.$?1090 
C HECKING AND LUBRICATING THE 
C ABLE S 
PERIODIC  MAINTENANCE 
Dam age /dete rioration -> Replace . 
•  Th rottl e cab le 
insta...

1 2 3 
d. Tigh ten the  lo ck nut. 
e. 
S li d e the  rub ber  cove r to  it s 

orig ina l posit ion. 
TIP
--------------­
Make  su re  that  the adjus ting nut  is  covered  com­
p lete ly 
by the  rubber  cover. 
EAW700 
CHECKING  AND CHARGING THE  BATTERY 
Re fe r  t o 
C H ECKING AND CHARGI NG THE 
BATTER Y o n  page  8-94. 
EAS:tl770 
CHECK ING THE FUSES 
Re

fe r  to 
CHECK IN G THE FU SE S on  pag e 
8-93. 
EAW700 
REPLACING THE HEADLIGHT BULB 
1. Remove: 
• Headlight un it  side  cover bolts  1...

6. Insta ll: 
•  He adligh t b ulb 
IH4W 
Secu re the  new headlight  bulb with  the head ­
li g ht bulb  ho lder. 
NOTICE ~~~~~~~~~~~~~ 
Avoid touching the glass part of the head ­
light bulb to keep it free from oil, otherwise 
the  transparency 
of the glass, the life of the 
bulb and  the luminous flux will be adversely 
affected. If the headlight bulb gets soiled , 
thoroughly clean it with a cloth moistened 
with 
alcohol or lacquer thinner. 
7 . Hook: 
•  Headlight  bulb  ho lder 
8 . Install: 
•...

PERIODIC MAINTENANCE 
3-31  

PERIODIC MAINTENANCE 
3-32  

CHASSIS 
GENERAL CHASSIS ... ....... .... .... ............ .... ........ ......................... ........ ............  .4-1 
REMOVING THE AIR SCOOPS ....... .... .... .... .... ........ ......... ........ ........ .... .... . 4-5 
INSTALLING THE AIR  SCOOPS ..... .... ..................... ........ ..................... ....  4-5 
INSTALLING THE FUEL TAN K MOLES ........................... ................. .... ....  4-5 
FRONT WHEEL  .....................................................

ASSEMBLING THE REAR BRAKE  MASTER CYLINDER ........ ........... ... .4-43 
INSTALLIN G THE REAR  BRAKE  MASTER CYLINDER ...... ............ ...... .4-43 
HANDLEBAR .............................................. ................................. ...................  4-44 
REMOVING THE HANDLEBAR  ...............................................................  4-4 5 
CHE CKING THE  HANDLEBAR  ..................... ........ ......................... .........  .4-45 
INSTALLIN G THE HANDLEBAR...