Kyocera TASKalfa 520i User Manual

English 
DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE 19
Emptying the Punch Waste Box
If a message is displayed on the machine operation panel indicating that the waste punch box is full, be sure to 
empty the scraps in the punch waste box. 
Leave the main power switch on the machine switched ON ( | ) while performing this procedure.
1Open the front cover.
2Grasp the punch waste box handle and remove 
the box from the Document Finisher.
NOTE: Take care not to spill the waste hole...

English 
20  DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE
Troubleshooting
Paper
If ejected copies are not flat or are stacked unevenly, 
turn over the paper in the cassette and reload it. If 
copies are curled, refer to Curled Output on page 31.
If a paper jam occurs, check the side guide located in 
the cassette is adjusted to the size of paper loaded.
Clearing Paper Jams
When a paper jam occurs, copying stops and the machine operation panel will display a message indicating a...

English 
DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE 21
2Remove the jammed paper.
3Open the tray C and front cover.
4Turn the conveyor knob (D2) to the left to feed the 
paper along to enable easy removal. 
5Close Tray C and the front cover, and re-install the 
finisher back into position on the machine. 
Tray A
If the illustration shown displays on the machine’s 
operation panel, there is a paper jam in the conveyor 
section to Tray A.
1Lift open Tray B and remove the jammed...

English 
22  DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE
2Open the front cover.
3Pull out the inner tray (D5).
4Open the inner tray cover (D6).
5Remove the jammed paper.
NOTE: If a jammed paper is located at the bottom of 
the tray and it is difficult to remove, lift the inner tray 
paper holder and remove the jammed paper from the 
lower side of the tray.
Downloaded From ManualsPrinter.com Manuals 

English 
DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE 23
6Close the inner tray cover (D6).
CAUTION: Close the inner tray cover (D6) securely 
until the magnet catches.
7Push the inner tray (D5) back into position and 
close the front cover.
Tray B
If the illustration shown displays on the machine’s 
operation panel, there is a paper jam in the conveyor 
section to Tray B.
1Remove any jammed paper from the ejection 
section. 
2Open the tray C.
Downloaded From ManualsPrinter.com...

English 
24  DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE
3Open the folding unit paper guide plate (D1) and 
remove the jammed paper.
4Open the front cover.
5Turn the conveyor knob (D2) to the left to feed the 
paper along to enable easy removal. 
6Close the folding unit paper guide plate (D1).
NOTE: Be sure to the close folding unit paper guide 
plate (D1). Failure to do so will cause paper jams.
7Close the tray C and front cover.
Tray  C
If the illustration shown displays on the...

English 
DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE 25
1While pushing the finisher release lever, pull the 
finisher out from the machine. 
2Open the top cover and remove the jammed paper.
3Close the top cover and re-install the finisher back 
into position on the machine. 
Conveyor / Inner Tray
If the illustration shown displays on the machines 
operation panel, there is a paper jam in the conveyor 
section to the inner tray.
NOTE:  If frequent jamming occurs in the conveyor or...

English 
26  DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE
Mailbox (option)
If the illustration shown displays on the machine’s 
operation panel, there is a paper jam in the Mailbox.
1Open the mailbox cover and remove the jammed 
paper.
2Close the mailbox cover.
Downloaded From ManualsPrinter.com Manuals 

English 
DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE 27
Center-Folding Unit (option)
Conveyor Section
If the illustration shown displays on the machine’s 
operation panel, there is a paper jam in the conveyor 
section of the Center-Folding Unit.
1While pushing the finisher release lever, pull the 
finisher out from the machine. 
2Open the right cover (D8) and remove the jammed 
paper.
If there is no paper jam in the right cover (D8), 
proceed to the following step. 
3Close the...

English 
28  DF-760(B), MT-720(B), BF-720, PH-5A, PH-5B AND PH-5C OPERATION GUIDE
6Open the inner tray cover (D6).
7Remove the jammed paper.
NOTE: If a jammed paper is located at the bottom of 
the tray and it is difficult to remove, lift the inner tray 
paper holder and remove the jammed paper from the 
lower side of the tray.
8Open the inner tray cover (D7) and remove the 
jammed paper.
9Close the inner tray cover (D6) and  inner tray 
cover (D7).
NOTE: Close the inner tray cover (D6) securely until...