IBM Thinkpad I Series 12001300 Manual

							2
Note:To remove the hard disk drive cover, let the top
cover of the computer a little open. Then you can
remove it more easily.
3
ThinkPad i Series 1200/1300141 
						

							WarningDo not drop or apply any shock to the hard disk
drive. The hard disk drive is sensitive to physical
shock. Incorrect handling can cause damage and
permanent loss of data on the drive.
Before removing the drive, have the user make a
backup copy of all the information on the drive if
possible.
Never remove the drive while the system is
operating or is in suspend mode.
1050 Hard disk drive kitting pack
v“1020 Battery assembly”on page 138
v“1040 Hard disk drive assembly”on page 140
1
2
Step Size (Quantity) Color Torque
1 M3 x 4L (1) Silver 3.2 kgf-cm
1060 CD-ROM assembly
v“1020 Battery assembly”on page 138
142ThinkPad i Series 1200/1300 HMM 
						

							1
2
Step Size (Quantity) Color Torque
1 M2.5 x 8L (1) Black 3.2 kgf-cm
3
Note:Some CD-ROM/CD-RW FRU (Delta CD-ROM and
KME CD-RW) have pick-up lens fixture sheet on
drives. Remove the sheet, before attach the drive to
system.
ThinkPad i Series 1200/1300143 
						

							1070 EZ key cover
v“1020 Battery assembly”on page 138
1
2
1080 Keyboard
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”
1
Step Size (Quantity) Color Torque
1 M2.5 x 8L (2) Black 3.2 kgf-cm
144ThinkPad i Series 1200/1300 HMM 
						

							2
54
3
Note:Make sure the FPC finger side is facing correct,
when inserted.
Notes:
1. When replacing the keyboard, make sure that the 2
cables are clean and insert them directly into the
connectors, making sure they make contact with the
bottom of the connector. Now press down on the latch
of the connector to secure.
2. If the cables do not touch the bottom of the connector,
the keyboard function will be rendered useless.
3. The cables of the keyboard are fragile and could be
damaged. Be careful when pulling out the cables.
1090 Backup battery
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
v“1080 Keyboard”on page 144
ThinkPad i Series 1200/1300
145 
						

							1
2
The below drawing applies to the following models:
1161-95G, 1161-95M, 1161-94T, 1161-94H, 1161-94G,
1161-94M, 1161-94A, 1161-94K, 1161-93U, 1161-93G,
1161-93F, 1161-93M, 1161-93C, 1161-93H, 1161-93K,
1161-93Y, 1161-93T, 1161-73J, 1161-53M, 1161-43U,
1161-43G, 1161-43M, 1161-43A, 1161-43T, 1161-43C,
1161-43K, 1161-43Y, 1161-43S, 1161-43P, 1161-43X,
1161-43H, 1161–96A, 1161–97A, 1161–96C, 1161–96Y,
1161–86C, 1161–96K, 1161–44F, 1161–4JU, 1161–45U,
1161–43A, 1161–45F, 1161–53U, 1161–83G, 1171–9BU,
1171–8MU, 1171-9MU, 1171-6MU, 1171-6NU, 1171-7XG,
1171-9XU, 1171-9XF, 1171-9XA, 1171-9XT, 1171-9XC,
1171-9XH, 1171-9XK, 1171-5XU, 1171-5XM, 1171-5CU,
1171-4MU, 1171-6XU.
CAUTION:
Danger of explosion if battery is incorrectly replaced.
Replace only with the same type. Dispose of used
batteries according to manufacturer’s instruction.
146ThinkPad i Series 1200/1300 HMM 
						

							Safety Notice 4Translation in″Safety Notices: Multi-lingual
Translations″section: The backup battery is a
lithium battery and can cause a fire, an explosion, or
severe burns. Do not recharge it, remove its
polarized connector, disassemble it, heat it above
100°C (212°F), incinerate it, or expose its cell
contents to water. Dispose of the battery as required
by local ordinances or regulations. Use of an
incorrect battery can result in ignition or explosion of
the battery. Replacement batteries can be ordered
from IBM or IBM Authorized Dealers.
1100 PCMCIA holder
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
v“1080 Keyboard”on page 144
1
ThinkPad i Series 1200/1300147 
						

							2
Step Size (Quantity) Color Torque
2 M2 x 6L (3) Silver with
Binding head1.6 kgf-cm
4
3
Note:Before removing and replacing the PCMCIA holder,
make sure that the PCMCIA cards are removed and
the eject levers are sticking out.
1110 Modem and Ethernet card cover
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
v“1080 Keyboard”on page 144
148ThinkPad i Series 1200/1300 HMM 
						

							12
Step Size (Quantity) Color Torque
1 M2.5 x 5L (2) Blue 3.2 kgf-cm
1120 Modem card
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
v“1080 Keyboard”on page 144
v“1110 Modem and Ethernet card cover”on page 148
2
1
Note:When you install the modem card, remember to
press it down and ensure the connection is well.
1130 Wireless Mini PCI card
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
ThinkPad i Series 1200/1300
149 
						

							v“1080 Keyboard”on page 144
v“1110 Modem and Ethernet card cover”on page 148
1
2
3
Note:To release the wireless LAN card cable, push the
cable removal tool (P/N 08K7159) as shown in the
drawing to the connector at 90 degree angle and
pull the cable out.
1140 Middle cover
v“1020 Battery assembly”on page 138
v“1070 EZ key cover”on page 144
v“1080 Keyboard”on page 144
150ThinkPad i Series 1200/1300 HMM