Motorola Xpr 7000 Seris Basic 68009498001 A Manual

Appendix A Replacement Parts Ordering
A.1 Basic Ordering Information
Some replacement parts, spare parts, and/or product information can be ordered directly. While parts 
may be assigned with a Motorola part number, this does not guarantee that they are available from 
Motorola Radio Products and Solutions Organization (RPSO). Some parts may have become 
obsolete and no longer available in the market due to cancelations by the supplier. If no Motorola 
part number is assigned, the part is normally not...

A-2Replacement Parts Ordering: Parts Identification
A.6 Parts Identification
The Radio Products and Solutions Organization*
(United States and Canada)
1-800-422-4210
A.7 Product Customer Service
Radio Products and Solutions Organization (United States and Canada)
1-800-927-2744
* The Radio Products and Solutions Organization (RPSO) was formerly known as the Radio 
Products Services Division (RPSD) and/or the Accessories and Aftermarket Division (AAD). 

Appendix B Motorola Service Centers
B.1 Servicing Information
If a unit requires further testing, knowledge and/or details of component level troubleshooting or 
service than is customarily performed at the basic level, please send the radio to a Motorola Service 
Center as listed below.
B.2 Motorola Service Center
1220 Don Haskins Drive.
Suite. A
El Paso, TX 79936
Telephone: 915-872-8200
B.3 Motorola Canadian Technical Logistics Center
Motorola Canada Ltd.
8133 Warden Avenue
Markham, Ontario, L6G 1B3...

Notes
B-2Motorola Service Centers: Motorola Federal Technical Center 

Appendix C Limited Level 3 Servicing
C.1 Maintenance
For details on the following, please refer to “Chapter 5 Disassembly/Reassembly Procedures” on 
page 5-1 to section 5.4 on page 5-4.
Section 5.2 on page 5-1 to Section 5.4 on page 5-4.
• Preventive maintenance (inspection and cleaning).
• Safe handling of CMOS and LDMOS devices.
• Repair procedures and techniques.
C.2 Chip Components
Use a Hot-Air Repair Station for chip component replacement. Adjust the temperature control to 
370°C (700°F), and...

C-2Limited Level 3 Servicing: Component and Parts list
C.3 Component and Parts list
Figure C-1.  PCB Top View
Figure C-2.  PCB Bottom View
SW40445
2 4
3
1
S4030
35
7 2 4
6
12
3
14 13 10
S4010
E0800
M0800 32 2
34
4
F4020
M4020
3
2
234
56 

Limited Level 3 Servicing: Component and Parts list C-3
Table C-1 Component Parts List
No.Circuit RefMotorola Part Num.Description
1 SW4044 4086470Z01 SPST Tact Switch
2 M0800
E08000987378K01
02012010001SM Coaxial Connector 
Female
3 S4010 40012023001 Frequency Switch
4 S4030 1875103C04 Volume Rotary On/Off 
Switch
5 M4020 0915184H01 Battery Contact 
Connector
6 F4020 6515076H01 Fuse Fast Blow 3A 24V 

Notes
C-4Limited Level 3 Servicing: Component and Parts list 

GlossaryGlossary
This glossary contains an alphabetical listing of terms and their definitions that are applicable to 
portable and mobile subscriber radio products. All terms do not necessarily apply to all radios, and 
some terms are merely generic in nature.
Te r mDefinition
AnalogRefers to a continuously variable signal or a circuit or device designed 
to handle such signals. 
BandFrequencies allowed for a specific purpose.
CPSCustomer Programming Software: Software with a graphical user 
interface...

Glossary-2
MHzMegahertz: One million cycles per second. Used especially as a radio-
frequency unit.
PagingOne-way communication that alerts the receiver to retrieve a message.
PC BoardPrinted Circuit Board. Also referred to as a PCB.
PLPrivate-Line Tone Squelch: A continuous sub-audible tone that is 
transmitted along with the carrier. 
Programming CableA cable that allows the CPS to communicate directly with the radio 
using USB.
ReceiverElectronic device that amplifies RF signals. A receiver separates...