Land Rover Freelander 2003my Electrical Library Rover Manual

INTRODUCTION
1.6FREELANDER 03MY
RRelay
RF Radio frequency
RH Right hand
RHD Right hand drive
ROW Rest of world
SRS Supplementary restraint system
VVolt
VIN Vehicle identification number
WWatt 

INTRODUCTION
FREELANDER 03MY 1.7
HOW TO USE THIS DOCUMENT
Fuse Details
Contains information on fuse functions and values and should be used together with the 
power distribution circuit diagrams to establish which systems share a common power 
supply and to ensure that correct value fuses are fitted.
Earth Points and Headers
Shows a plan view of the vehicle with location of all earth points. Supporting photographs 
and connector detail information appear in the Connector section.
Description and...

INTRODUCTION
1.8FREELANDER 03MY
1.Cav:  The connector pin (cavity) number.
2.Col:  The colour of wire populating the connector pin.
3.Cct:  Identifies the model or feature which uses the wire. ALL means applicable to all 
models in the range fitted with the feature or system in question. In instances where 
different models, features or systems require different colour wires to be fitted in a 
cavity, each instance of the cavity is included in the pin-out table.
NOTE: Wires may not be fitted to all...

INTRODUCTION
FREELANDER 03MY 1.9
FAULT DIAGNOSIS
General
When diagnosing an electrical fault, follow the steps below:
1. Read the circuit description appropriate to the reported fault to ensure a good 
understanding of circuit operation.
2. Study the power distribution, fuse details and earth distribution diagrams and identify 
other circuits which share fuses and/or earth points. Check whether these circuits 
operate correctly.
3. Using the photographs contained in the Connector section, locate a point...

INTRODUCTION
1.10FREELANDER 03MY
WIRE COLOUR CODES
General
The following list contains wire colour codes used on the vehicle harnesss.
Code Colour
BBlack
GGreen
KPink
LG Light green
NBrown
OOrange
PPurple
RRed
S Slate (Grey)
T Transparent
UBlue
WWhite
YYellow 

FUSE DETAILS
FREELANDER 03MY 2.1
F USE DETAILSIntroduction
Fuses are mounted in one of two fuse boxes. One fuse box is located in the LH rear side of 
the engine compartment, and the other is located behind the driver side cubby box.
The engine compartment fuse box contains three different types of fuse:
1.Blade type fuse  – Small, pull out, male fuse, used to protect circuits from 5 A to 30 A.
2.J–case fuse  – Square shaped, pull out, female fuse, used to protect circuits from 30 
A to 60 A.
3.Bolt down...

FUSE DETAILS
2.2FREELANDER 03MY
ENGINE COMPARTMENT FUSE BOX
Relays (R)
1. Fuel pump relay.
2. Starter relay.
3. HDC relay.
4. Main relay.
5. ECM relay (NAS only).
6. Horn relay.
7. A/C compressor clutch relay. 

FUSE DETAILS
FREELANDER 03MY 2.3
LinkRatingVe hi cl eFunction
FL1 150 A All Alternator, FL2, FL7, FL10, fuse 5, fuse 8 and fuse 9 
of the engine compartment fuse box.
FL2 60 A All Ignition switch.
FL3 60 A All Ignition switch.
FL4 80 A All CCU, window lift relay, auxiliary relay, HRW relay, 
and fuse 9, fuse 13, fuse 14, fuse 15, fuse 30, fuse 
31 and fuse 32 of the passenger compartment fuse 
box.
FL5 80 A A/C fitted Cooling fan control unit
FL5 40 A Non A/C Cooling fan relay.
FL6 100 A NAS Not used....

FUSE DETAILS
2.4FREELANDER 03MY
FuseRatingVe h icleFunction
F1 15 A Td4 Glow plug relay.
F1 15 A K1.8 Purge control valve, HO2S
F1 15 A KV6 HO2S, splice joint 14.
F1 15 A NAS Fuel pump, splice joint 14.
F2 20 A Td4 ECM.
F2 20 A K1.8 ECM, fuel injectors, splice joint 1.
F2 20 A KV6 ECM, fuel injectors, splice joint 15.
F2 20 A NAS ECM, header 294.
F3 15 A K1.8 Splice joint 2
F3 15 A KV6 Splice joint 13.
F3 15 A NAS Header 294.
F4 15 A Td4 Splice joint 51, A/C compressor clutch relay, E-Box 
temperature...

FUSE DETAILS
FREELANDER 03MY 2.5
PASSENGER COMPARTMENT FUSE BOX
Relays (R)
1. Main/Dipped beam relay
2. HRW relay
3. Accessory socket relay
4. Auxiliary relay
5. Window lift relay
6. Flasher unit