Land Rover Defender Workshop 1993 Rover Manual

RECOMMENDED LUBRICANTS. FLUIDS AND CAPACITIES 
CAPACITIES 
The following  capacity  figures  are  approximate  and are provided  as a guide  only . All oil levels must be  set 
using the  dipstick or level plugs  as applicable 
. 
Component  Litres  Imperial units 
Engine sump oil ........................................................................\
..................... 9.00 pints 5,10 
1.00 pint 
Main gearbox oil.  five
-speed LT77S .................................................................

MAINTENANCE 
WORKSHOP MAINTENANCE  SCHEDULES 
The following  maintenance  should  be carried out by trained  personnel  in a fully  equipped  workshop.  If the 
vehicle  is operating  in a  remote  area  where  workshop facilities  are  not available,  maintenance  and  repair work 
should  be carried  out by experienced  mechanics in safe  conditions.  Maintenance should  normally  be carried  out 
at  7,500  miles  (12,000 km)  intervals  or six  months,  whichever  is  first, as described  in the...

MAINTENANCE 
ALL NORTH AMERICAN MODELS 
First  1000 miles  (1600km)  service 
only 
Renew engine oil. 
Check/top  up transfer  box oil. 
Renew  front axle oil. 
Renew  rear axle  oil. 
Renew  steering  swivel housing  oil. 
Chec/top  up power  steering  fluid. 
Check/top  up transmission  oil.  Check operation 
of all instruments,  fuel and 
Check/top  up clutch  and brake  m/c fluid  level.  temperature gauges, warning  indicators,  lamps, 
Check  for oil/fluid  leaks from:  horns and audio  unit....

MAINTENANCE 
CALIFORNIA 
California  models 
- For maintenance  after 45,000 miles (72,000 km) we recommend  that the U.S.A. 
Required  Maintenance’  is carried  out in addition  to the  ’Recommended  Maintenance’ list. 
NOTE:  The next  service  is due  in six  months 
if you  drive  less than 7,500 miles  (12,000  km). 
REISSUED:  FEB 1993 
3  

MAINTENANCE 
4 REISSUED: FEB 1993  

MAINTENANCE 
REISSUED: FEB 1993 5  

MAINTENANCE  

MAINTENANCE 
REISSUED: FEB 1993 7  

MAINTENANCE 
It is  recommended  that: 
At 15,000 mile (24,000 km) intervals  or every 18 months,  whichever  is the  sooner,  the hydraulic  brake and 
clutch  fluid should 
be completely  renewed. 
At 37,500 mile (60,000 km) intervals  or every  3 years,  which ever is the  sooner,  all hydraulic  brake and fluid, 
seals  and flexible  hoses should  be renewed,  all working  surfaces  of the  master  cylinder,  wheel cylinders  and 
caliper  cylinders  should be examined  and renewed  where necessary....

MAINTENANCE 
LUBRlCATlON 5. Clean the outside  of the  oil filler  cap,  remove 
it from  the rocker  cover and clean  the inside. 
This  first part  of the  maintenance  section covers 
6. Pour in the  correct  quantity  of new  oil of the 
renewal  of lubricating  oils for the  major  units of the  correct grade from a sealed  container 
to the 
vehicle  and other  components  that require  high mark  on the  dipstick  and firmly  replace 
lubrication,  as detailed  in the  MAINTENANCE  the filler...