IBM Thinkpad T30 Manual

							2030 LCD panel and LCD cable
assembly
For access, remove these FRUs, in order:
v“1010 Battery pack”on page 61
v“1020 Ultrabay Plus device”on page 62
v“1050 Backup battery”on page 67
v“1070 Mini PCI adapter”on page 71
v“1080 Communication daughter card (CDC)”on page 74
v“1030 Hard-disk drive”on page 63
v“1090 Keyboard”on page 77
v“1120 Keyboard bezel”on page 87
v“1130 Hinge cover”on page 92
v“1140 LCD assembly”on page 94
v“2010 LCD front bezel”on page 114
v“2020 Inverter card”on page 115
ImportantLCD panel FRUs for the ThinkPad T30 series are
supplied by different vendors and differ in resolution
and base brightness. When you order and replace
the LCD panel FRU, note the following:
vThe LCD panel FRU must be used with the
inverter card corresponding to the base
brightness.
vReplace the new LCD panel FRU with one from
the same vendor, and having the same resolution
and base brightness as the defective LCD panel.
vIf no LCD panel FRU with the same base
brightness as the defective LCD panel is
available, use an“LCD panel and inverter kit”
from the same vendor, with the same resolution.
vFor more details about the FRU numbers or the
combination of the LCD panel FRU and the
inverter card FRU, see“LCD FRUs”on page 149.
Removing and replacing a FRU
ThinkPad T3011 7 
						

							1
1
1
1
Step Screw (quantity) Torque

1M2×5.7 mm, nylon-coated (4) 0.245 Nm
(2.5 kgfcm)
45
2
3
(continued)
Removing and replacing a FRU
11 8ThinkPad T30 (MT 2366, 2367) 
						

							6
6
When installing the LCD panel, do the following:
vPlace the FPC connector under the black antenna
cable.
vMake sure that the antenna cables are firmly routed to
fit to the cable guides of the LCD cover.
vMake sure that the antenna cables are not pinched
under the LCD panel.
Removing and replacing a FRU
ThinkPad T3011 9 
						

							2040 Antenna assembly, hinges, and
LCD cover
For access, remove these FRUs, in order:
v“1010 Battery pack”on page 61
v“1020 Ultrabay Plus device”on page 62
v“1030 Hard-disk drive”on page 63
v“1050 Backup battery”on page 67
v“1070 Mini PCI adapter”on page 71
v“1080 Communication daughter card (CDC)”on page 74
v“1090 Keyboard”on page 77
v“1120 Keyboard bezel”on page 87
v“1130 Hinge cover”on page 92
v“1140 LCD assembly”on page 94
v“2010 LCD front bezel”on page 114
v“2020 Inverter card”on page 115
v“2030 LCD panel and LCD cable assembly”on page 117
1
1
Step Screw (quantity) Torque

1M2.5×4.8 mm, nylon-coated (2) 0.392 Nm
(4 kgfcm)
(continued)
Removing and replacing a FRU
120ThinkPad T30 (MT 2366, 2367) 
						

							2
2
3
Removing and replacing a FRU
ThinkPad T30121 
						

							To install the antenna assembly, do as follows:
1. Attach the antenna assembly to the hinge, aligning the
screw hole and the claws
awith the edge of the
hinge.
Note:Attach the gray cable(MAIN)to the left side and
the black cable(AUX)to the right side of the
LCD cover.
1
2
2
a
2. Place the antenna assembly on the LCD cover.
(continued)
Removing and replacing a FRU
122ThinkPad T30 (MT 2366, 2367) 
						

							3. Make sure that the antenna assembly and hinges are
firmly attached; there are some projections (
b,
c)
on the LCD cover to fix the antenna assembly into
place. And then, route the gray cable as in this figure.
b
c
33
(continued)
Removing and replacing a FRU
ThinkPad T30123 
						

							4. Route the black cable as in figures
4and
5.
44
5
5. Secure the antenna assembly and hinges with screws
to the LCD cover.
Removing and replacing a FRU
124ThinkPad T30 (MT 2366, 2367) 
						

							3010 ThinkPad Dock PCI cover
Before replacing the PCI cover:
There are two types of ThinkPad Dock, as follows:
vThinkPad Dock: FRU no. 08N1546 (PCI cover: FRU no.
05K6246)
vThinkPad Dock with extension plate: FRU no. 08N1537
(PCI cover: FRU no. 08N7317)
Confirm the FRU no. of the ThinkPad Dock first and
choose the proper PCI cover FRU for the ThinkPad Dock
you are servicing.
Removing and replacing a FRU
ThinkPad T30125 
						

							Note:The following illustration shows how to remove the
PCI cover of ThinkPad Dock (FRU no. 08N1546).
Do the same to remove the PCI cover of ThinkPad
Dock with extension plate (FRU no. 08N1537).
1
2
1
(Bottom view)
Removing and replacing a FRU
126ThinkPad T30 (MT 2366, 2367)