HP P2055 Manual

5.Rotate the drive end of the roller assembly out and away from the product.
Figure 6-12   Remove the pickup roller assembly; Tray 2 (4 of 5)
6.Remove the pickup roller.
CAUTION: The two rollers on the end of the assembly ar e not captive and can slip off of the roller
shaft. Do not lose the rollers when you remove the assembly.
Figure 6-13   Remove the pickup roller; Tray 2 (5 of 5)
ENWW Rollers and pads 109 

Separation-pad assembly; Tray 2
CAUTION:Do not touch the pad surface unless you are replacing the pad. Skin oils on the pad can
cause paper-pickup problems.
1. If the Tray 2 cassette has not yet been removed to service the product, remove the cassette. See
Tray 2 cassette on page 103.
2. Remove two screws (callout 1)
Figure 6-14   Remove the separation-pad assembly; Tray 2 (1 of 2)
1
3.Remove the separation-pad assembly.
Figure 6-15   Remove the separation-pad assembly; Tray 2 (2 of 2)
110 Chapter 6...

Transfer roller
CAUTION:Do not touch the sponge surface of the roller  unless you are replacing the roller. Skin oils
on the roller can cause print-quality problems.
Always wear latex gloves when handling a tran sfer roller for reinstallation or replacement.
1.Press the print-cartridge door button (callout  1), and then open the print-cartridge door.
Figure 6-16   Remove the transfer roller (1 of 5)
1
2.Use your finger to raise the sheet-metal flap, and th en rotate it toward the Tray 1 pickup roller...

3.Before you proceed, note the location of the two  tabs on the transfer-roller right-side locking clip.
Figure 6-18   Remove the transfer roller (3 of 5)
4.Release two tabs on the right-side locking clip, lift  the roller up, and then slide it toward the right
side of the product to release the left end of the shaft.
Figure 6-19   Remove the transfer roller (4 of 5)
2
1
112 Chapter 6   Removal and replacement ENWW 

5.Remove the transfer roller.
CAUTION: The black locking clip on the right side of  the transfer-roller shaft is not captive. Do
not lose the locking clip when  you remove the transfer roller.
Figure 6-20  Remove the transfer roller (5 of 5)
ENWW Rollers and pads 113 

External panels, covers, and doors
NOTE:Your product might not appear exactly as the on e shown in the photos in this chapter. For
example, the color of the external panels and covers  might be different than your product. However, the
procedures in this chapter are valid for both th e HP LaserJet P2035 and the HP LaserJet P2055.
DIMM door (HP LaserJet P2050 Series only)
1.Open the DIMM door.
Figure 6-21   Remove the DIMM door (1 of 2; HP LaserJet P2050 Series only)
2.Pull the DIMM door away from the...

Right cover
CAUTION:The power switch can be dislodged when the ri ght cover is removed. Be careful when you
remove the cover. If the switch is dislodged, see 
Reinstall the right cover on page 117 .
1. Press the print-cartridge door button (callout  1), and then open the print-cartridge door.
Figure 6-23   Remove the right cover (1 of 5)
1
2.Lift the rear door latch (callout  2), and then open the rear door.
Figure 6-24   Remove the right cover (2 of 5)
2
ENWW External panels, covers, and doors 115 

3.Before you proceed, note of the locations of the mounting tabs on the right cover.
Figure 6-25   Remove the right cover (3 of 5)
4.Release three tabs (callout 3).
Figure 6-26   Remove the right cover (4 of 5)
3
116 Chapter 6   Removal and replacement ENWW 

5.Carefully slide the cover toward the fron t of the product, and then remove it.
Figure 6-27   Remove the right cover (5 of 5)
Reinstall the right cover
If the power switch is disl odged when the cover is removed, replace it before installing  the right cover.
Figure 6-28   Reinstall the right cover
ENWW External panels, covers, and doors 117 

Left cover
1.Press the print-cartridge door button (callout  1), and then open the print-cartridge door.
Figure 6-29   Remove the left cover (1 of 4)
1
2.Grasp the top front of  the cover, and then gently separ ate the cover from the product.
Figure 6-30   Remove the left cover (2 of 4)
118 Chapter 6   Removal and replacement ENWW