dell latitude c610 c510 User Manual

							System Components: Dell Latitude C610/C510 Service Manual
7right speaker 16palm rest
8 modem and network-adapter connector covers 17keyboard
9 fan guard   
Back to Contents Page
 
 
 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/system.htm (3 of 3)\
 [2/28/2004 7:55:44 AM] 
						

							Hard Drive: Dell Latitude C610/C510 Service Manual
Back to Contents Page 
Hard Drive 
Dell™ Latitude™ C610/C510 Service Manual
  Removing the Hard Drive 
  Replacing the Hard Drive 
Removing the Hard Drive 
1.  Save and close any open files, exit any open programs, and shut down the\
 computer. 
NOTICE: Disconnect the computer and any attached devices from electrical 
outlets, and remove any installed batteries. 
NOTICE: The hard drive is very sensitive to shock. Handle the hard drive by its \
edges (do not squeeze the top of the hard drive case), and avoid dropp\
ing it. 
NOTICE: Read Preparing to Work Inside the Computer before performing the 
following procedure. 
NOTICE: To prevent data loss, turn off your computer before removing the 
hard drive. Do not remove the hard drive while the computer is running, \
in 
standby mode, or in hibernate mode. 
  CAUTION: If you remove the hard drive from the computer when the 
drive is hot, do not touch the metal housing of the hard drive.
2.  Ground yourself by touching a metal connector on the back of the compute\
r. 
3.  Turn the computer over. Remove the M3 x 5-mm screw from the hard drive  door. 
Hard Drive Removal 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/hdd.htm (1 of 3) [\
2/28/2004 7:55:45 AM] 
						

							Hard Drive: Dell Latitude C610/C510 Service Manual
 
1 bottom of computer
2 M3 x 5-mm screw
3 hard drive door
4.  Lift up the hard drive door until you hear a click. 
5.  Slide the hard drive out of the computer. 
Replacing the Hard Drive 
NOTICE: Use firm and even pressure to slide the hard drive into place. If you 
force the hard drive into place using excessive force, you may damage th\
e 
connector. 
1.  Lift up the hard drive door until you hear a click. Push the hard drive \
into the  drive bay until it is fully seated in the bay. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/hdd.htm (2 of 3) [\
2/28/2004 7:55:45 AM] 
						

							Hard Drive: Dell Latitude C610/C510 Service Manual
2.  Press the hard drive door down. 
3.  Replace the M3 x 5-mm screw in the hard drive door. 
Back to Contents Page
 
 
 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/hdd.htm (3 of 3) [\
2/28/2004 7:55:45 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
Back to Contents Page 
Memory Modules, Mini PCI Card, and 
Modem 
Dell™ Latitude™ C610/C510 Service Manual
  Memory Modules
  Mini PCI Card
  Modem
Memory Modules
Removing the Memory Module Cover 
NOTICE: Disconnect the computer and any attached devices from electrical 
outlets, and remove any installed batteries. 
NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by 
touching an unpainted metal surface on the computer. 
NOTICE: Read Preparing to Work Inside the Computer before performing the 
following procedure. 
1.  Turn the computer over, and use a flat-blade screwdriver to release the \
two  captive screws from the memory module cover. 
2.  Remove the M2.5 x 12-mm screw labeled circle K. (The screw is one of \
the  five keyboard screws.) 
3.  Place your finger under the cover at the indentation and lift and slide \
the cover  open. 
Memory Module Cover 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (1 of \
8) [2/28/2004 7:55:46 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
 
1 M2.5 x 12-mm screw (1)
2 captive screws (2)
Removing the Memory Modules 
NOTICE: Disconnect the computer and any attached devices from electrical 
outlets, and remove any installed batteries. 
NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by 
touching an unpainted metal surface on the computer. 
NOTICE: Read Preparing to Work Inside the Computer before performing the 
following procedure. 
1.  Remove the 
memory module cover. 
NOTICE: To prevent damage to the memory module connector, do not use 
tools to spread the inner metal tabs that secure the memory module. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (2 of \
8) [2/28/2004 7:55:46 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
2.  Use your fingertips to carefully spread apart the inner tabs on each end\
 of the memory module socket. 
The module should pop up.
Memory Module Removal 
 
1 JDIM 1
2 JDIM 2
3 memory module sockets (2)
4 inner tabs (2 per socket)
3.  Lift the memory module out of its socket. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (3 of \
8) [2/28/2004 7:55:46 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
Replacing the Memory Modules 
1.  If you only have one memory module, install it in the connector labeled \
JDIM1 on the system board. Install a second memory module in the connector lab\
eled 
JDIM2. 
NOTE: Memory modules are keyed, or designed to fit into their sockets, in only\
 
one direction. 
NOTICE: The memory module must be inserted at a 45-degree angle to avoid 
damaging the connector. 
2.  Align the notch in the memory module with the slot in the center of the \
socket. 
3.  Slide the edge connector of the module firmly into the socket at a 45-degree angle, and rotate the module down until you hear a click. If y\
ou do 
not hear the click, remove the module and reinstall it. 
4.  Replace the cover and tighten the two captive screws. 
Mini PCI Card
You must remove the Mini PCI card before the system board can be removed\
.
Removing the Mini PCI Card 
NOTICE: Disconnect the computer and any attached devices from electrical 
outlets, and remove any installed batteries. 
NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by 
touching an unpainted metal surface on the computer. 
NOTICE: Read Preparing to Work Inside the Computer before performing the 
following procedure. 
1.  Remove the 
memory module cover. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (4 of \
8) [2/28/2004 7:55:46 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
2.  Disconnect the Mini PCI card from the antenna cables. 
3.  To release a Mini PCI card from its socket, spread apart the metal secur\
ing tabs until the card pops up slightly. 
4.  Lift the Mini PCI card out of its connector. 
Mini PCI Card 
 
1 antenna connectors on card (2)
2 antenna cables (2)
Replacing the Mini PCI Card 
1.  Align the Mini PCI card with the socket at a 45-degree angle, and press \
the Mini 
PCI card into the socket. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (5 of \
8) [2/28/2004 7:55:46 AM] 
						

							Memory Modules, Mini PCI Card, and Modem: Dell Latitude C610/C510 Servic\
e Manual
NOTICE: The connectors are keyed for correct insertion; do not force the 
connections. 
2.  Lower the Mini PCI card toward the inner tabs to approximately a 20-degree angle. 
3.  Continue lowering the Mini PCI card until it snaps into the inner tabs o\
f the  socket. 
4.  Attach the antenna cables to the Mini PCI card. 
5.  Replace the cover and tighten the two captive screws. 
Modem
Removing the Modem 
NOTICE: Disconnect the computer and any attached devices from electrical 
outlets, and remove any installed batteries. 
NOTICE: To avoid ESD, ground yourself by using a wrist grounding strap or by 
touching an unpainted metal surface on the computer. 
NOTICE: Read Preparing to Work Inside the Computer before performing the 
following procedure. 
1.  Turn the computer over, and remove the 
memory module cover. 
2.  Remove the two M2 x 3-mm screws that secure the modem to the system  board. 
NOTICE: Do not pull on the modem cable. Pull from the modem connector to 
disconnect the cable. 
3.  Pull straight up on the attached pull tab to lift the modem out of its c\
onnector on  the system board and disconnect the modem cable. 
file:///F|/Service%20Manuals/Dell/Latitude/c510-610/upgrades.htm (6 of \
8) [2/28/2004 7:55:46 AM]