Acer Extensa 5630z Service Guide

							TravelMate 5330
Extensa 5230/5630Z Series
Service Guide
    
                                                                                                                                     PRINTED IN TAIWAN Service guide files and updates are available
on the ACER/CSD web; for more information, 
please refer to http://csd.acer.com.tw 
						

							II
Revision History
Please refer to the table below for the updates made on TravelMate 5330/Extensa 5230/5630Z Series service 
guide.
DateChapterUpdates 
						

							III
Copyright
Copyright © 2008 by Acer Incorporated. All rights reserved. No part of this publication may be reproduced, 
transmitted, transcribed, stored in a retrieval system, or translated into any language or computer language, in 
any form or by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without 
the prior written permission of Acer Incorporated.
Disclaimer
The information in this guide is subject to change without notice.
Acer Incorporated makes no representations or warranties, either expressed or implied, with respect to the 
contents hereof and specifically disclaims any warranties of merchantability or fitness for any particular 
purpose. Any Acer Incorporated software described in this manual is sold or licensed as is. Should the 
programs prove defective following their purchase, the buyer (and not Acer Incorporated, its distributor, or its 
dealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential 
damages resulting from any defect in the software. 
Acer is a registered trademark of Acer Corporation.
Intel is a registered trademark of Intel Corporation.
Pentium and Pentium II/III are trademarks of Intel Corporation.
Other brand and product names are trademarks and/or registered trademarks of their respective holders. 
						

							IV
Conventions
The following conventions are used in this manual:
SCREEN MESSAGESDenotes actual messages that appear 
on screen.
NOTEGives bits and pieces of additional 
information related to the current 
topic.
WARNINGAlerts you to any damage that might 
result from doing or not doing specific 
actions.
CAUTIONGives precautionary measures to 
avoid possible hardware or software 
problems.
IMPORTANTReminds you to do specific actions 
relevant to the accomplishment of 
procedures. 
						

							V
Preface
Before using this information and the product it supports, please read the following general information.
1.This Service Guide provides you with all technical information relating to the BASIC CONFIGURATION 
decided for Acers global product offering. To better fit local market requirements and enhance product 
competitiveness, your regional office MAY have decided to extend the functionality of a machine (e.g. 
add-on card, modem, or extra memory capability). These LOCALIZED FEATURES will NOT be covered 
in this generic service guide. In such cases, please contact your regional offices or the responsible 
personnel/channel to provide you with further technical details.
2.Please note WHEN ORDERING FRU PARTS, that you should check the most up-to-date information 
available on your regional web or channel. If, for whatever reason, a part number change is made, it will 
not be noted in the printed Service Guide. For ACER-AUTHORIZED SERVICE PROVIDERS, your Acer 
office may have a DIFFERENT part number code to those given in the FRU list of this printed Service 
Guide. You MUST use the list provided by your regional Acer office to order FRU parts for repair and 
service of customer machines. 
						

							VI 
						

							1
Chapter 1 System Specifications  1
Features  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
System Block Diagram  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Your Acer Notebook tour   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Right View  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Indicators   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Easy-Launch Buttons   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Touchpad Basics (with fingerprint reader)   . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Touchpad basics (with two-click buttons)  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Using the Keyboard   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Lock Keys and embedded numeric keypad   . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Windows Keys   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Hot Keys  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Special Key (only for certain models)  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Acer Empowering Technology   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Launching Acer Empowering Technology   . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Empowering Technology password   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Acer ePower Management  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
Acer eDataSecurity Management (only for certain models)  . . . . . . . . . . . . . . . .20
Acer eRecovery Management   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21
Acer eSettings Management   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23
Windows Mobility Center   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Using the System Utilities  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25
Acer GridVista (dual-display compatible)   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Hardware Specifications and Configurations   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Chapter 2 System Utilities  35
BIOS Setup Utility  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35
Navigating the BIOS Utility  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Information   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37
Main   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38
Security  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44
Exit   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45
BIOS Flash Utility  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46
Remove HDD/BIOS Utility   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47
Chapter 3 Machine Disassembly and Replacement  51
Disassembly Requirements   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .51
General Information   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Pre-disassembly Instructions   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Disassembly Process  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
External Module Disassembly Process   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53
External Modules Disassembly Flowchart   . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53
Removing the Battery Pack   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54
Removing the SD dummy card  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55
Removing the PC and ExpressCard dummy cards   . . . . . . . . . . . . . . . . . . . . . .56
Removing the Lower Cover   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57
Removing the DIMM  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58
Removing the WLAN Board Modules  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .59
Removing the Hard Disk Drive Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .61
Removing the Optical Drive Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Table of Contents 
						

							2
Main Unit Disassembly Process  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65
Main Unit Disassembly Flowchart  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65
Removing the Middle Cover  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Removing the Power Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67
Removing the Keyboard  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69
Removing the Heatsink Fan Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Removing the CPU and VGA Heatsink Module   . . . . . . . . . . . . . . . . . . . . . . . . .71
Removing the CPU  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72
Removing the VGA Board (Discrete Model only)   . . . . . . . . . . . . . . . . . . . . . . . .73
Removing the LCD Module  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74
Separating the Upper Case from the Lower Case  . . . . . . . . . . . . . . . . . . . . . . .76
Removing the Speaker Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
Removing the Launch Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81
Removing the Fingerprint and Touchpad Module  . . . . . . . . . . . . . . . . . . . . . . . .82
Removing the Modem Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85
Removing the USB Board Module   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87
Removing the Main Board   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88
 LCD Module Disassembly Process  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
LCD Module Disassembly Flowchart   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
Removing the LCD Bezel  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92
Removing the LCD module with the Brackets   . . . . . . . . . . . . . . . . . . . . . . . . . .94
Removing the FPC Cable  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95
Removing the LCD Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97
Removing the Antennas  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98
Removing the Web Camera  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99
Chapter 4 Troubleshooting  101
System Check Procedures  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
External Diskette Drive Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
External CD-ROM Drive Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
Keyboard or Auxiliary Input Device Check   . . . . . . . . . . . . . . . . . . . . . . . . . . . .102
Memory check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103
Power System Check  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103
Touchpad Check  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105
Power-On Self-Test (POST) Error Message   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106
Index of Error Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .107
Phoenix BIOS Beep Codes   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110
Index of Symptom-to-FRU Error Message  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .115
Intermittent Problems  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119
Undetermined Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120
Chapter 5 Jumper and Connector Locations 121
Top and Bottom View  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .121
BIOS Recovery by Crisis Disk   . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124
Chapter 6 FRU (Field Replaceable Unit) List  125
TravelMate 5330 Series Exploded Diagram  . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126
Extensa 5230/5630Z and TravelMate 5330 Series   . . . . . . . . . . . . . . . . . . . . . . . . .134
Appendix A Model Definition and Configuration  134
Extensa 5230/5630Z and TravelMate 5330 Series   . . . . . . . . . . . . . . . . . . . . . . . . .134
Table of Contents 
						

							3
Appendix B Test Compatible Components  135
Microsoft® Windows® Vista Environment Test   . . . . . . . . . . . . . . . . . . . . . . . . . . . .136
Appendix C Online Support Information  139
Index 141
Table of Contents 
						

							4