Sony Vaio Sony Vaio Vgnfj Manual

							FJ Series
Confidential
Chapter 1. Disassembly & Assembly Guide
1.MS-1-D.1
1-3. Disassembly & Assembly
- Main Section -
MS-1 Main Section Disassembly 
						

							FJ Series
Confidential
Battery Pack
1)2)1.MS-1-D.2
Slide the Button (Battery) to UNLOCK position.
While sliding the Button (Battery) to RELEASE side, 
remove the Battery Pack.
Button (Battery)
Battery Pack
Button (Battery) 
						

							FJ Series
Confidential
Memory
1)2)1.MS-1-D.3
Remove the one screw, and the Door (RAM).
* There are two detents on the front. 
* This screw is built-in screw of the Door (Memory).
Door (RAM)
3)
Tab
Memory
Peel off the Mylar.
* There are Cushion (one place) under the Mylar.
Outspread the tabs (two places) simultaneously to release the lock 
and pull out the Memory in the direction of the arrow.
* If there are two Memory, remove the other side of the Memory as 
the same procedure as above.
CushionMylar 
						

							FJ Series
Confidential
HDD-1
1)2)1.MS-1-D.4
Remove the two screws. 
* These screws are built-in screws of the Door (HDD).
Raise the front side of the HDD, and remove it toward the front.
* When removing the HDD, pay attention to the convex portion.Remove the Door (HDD) toward the front. 
* There are two detents on the front.
3)
Remove the two screws, and disconnect the connector portion by 
sliding it in the direction of the arrow.
4)
Door (HDD)
Detent
Connector
HDD
Convex
Door (HDD)
Detent
Screw:B3 
						

							FJ Series
Confidential
HDD-2
5)1.MS-1-D.4(a)
Peel off the Mylar (one place).
Mylar 
2[ADD]
2[ADD] 
						

							FJ Series
Confidential
Parts of the HDD
1)2)1.MS-1-D.5
Remove the Bracket (two places).
Bracket (HDD-Front)
Bracket (HDD-Rear)
Screw: B7
Remove the two screws each on the right and left sides. 
						

							FJ Series
Confidential
Screws (Bottom)
1)1.MS-1-D.6
Screw: B2
Remove the 11 screws.
Screw securing the Keyboard 
						

							FJ Series
Confidential
Keyboard
1.MS-1-D.73) 4)
Disengage the detent (four places). 
* Push the detent lightly downward, and the detent is disengaged. 
* There are detents around the F1, F5, F11, and Insert key. Raise the Keyboard toward the front. 
* The FPC is connected to the Keyboard.
Remove the FPC upward.
1)
Keyboard
Slide the lock lever upward and release the lock.
2)
FPC
Lock Lever
Detent
Detent 
						

							FJ Series
Confidential
Keyboard Bracket, Optical Disc Drive
1)1.MS-1-D.8
Remove the four screws.
2)
Slide the Bracket (Keyboard) in the direction of the arrow and remove it.
3)
Disconnect the connector by sliding the Optical Disc Drive in the 
direction of the arrow, and remove the Optical Disc Drive.
Optical Disc Drive
Bracket (Keyboard)
Connector
[DEL]
10
[CHG]4
Screw: Blue-B1 , Red-B2
4)
Screw: B1
Remove the screw.
* Except 4th Model: One place
* 4th Model: Two places
[ADD]
10
4th ModelCommon
[MA]
10 
						

							FJ Series
Confidential
Palmrest-1
1)1.MS-1-D.93)
Close the Display, turn over the Main Unit, and remove the three screws.
2)
4)Slide the lock lever in the direction of the arrow to release the lock,
and disconnect the FFC (one place).
FFC (Touch Pad SW-MAIN)
Screw: B3
Felica Model
FFC (Power SW-Main)
Lock Lever
Slide the lock lever upward to release the lock, and 
disconnect the FFC (one place).
FFC (Felica)Lock Lever
Slide the lock lever upward to release the lock, and 
disconnect the FFC (one place).
Lock Lever