Land Rover Defender V8i Workshop Supplement Rover Manual

GENERAL SPECIFICATION DATA
1
INFORMATION ENGINE 4.0 V8i
Type V8i.................................................................................
Number of cylinders Eight, two banks of four.........................................................
Bore 94,00 mm................................................................................. 3.70 in
Stroke 71,12 mm............................................................................... 2.80 in
Capacity 3950 cm...

04GENERAL SPECIFICATION DATA
2
INFORMATION Pistons
Clearance in bore, measured at bottom
of skirt at right angles to piston pin 0,020-0,050 mm................................... 0.0008-0.0020 in
Piston rings
Number of compression rings 2..........................................
Number of oil control rings 1...............................................
No 1 compression ring Molybdenum barrel faced.....................................................
No 2 compression ring Tapered and marked T or...

GENERAL SPECIFICATION DATA
3
INFORMATION ENGINE MANAGEMENT SYSTEM (GEMS)
Fuel system type Sagam-Lucas GEMS hot wire system electronically..............................................................
controlled
Fuel pump type High pressure electrical, immersed in the fuel tank................................................................
Fuel pump delivery pressure 2.4-2.6 bar............................................ 34-37 lbf/in
2
Fuel filter In-line filter canister...

04GENERAL SPECIFICATION DATA
4
INFORMATION Intake air temperature sensor
Make and type Lucas 10TT.................................................................
Ignition coils
Make and type Lucas 2DIS2.................................................................
COOLING SYSTEM
Type Pressurized system with cross-flow radiator and.................................................................................
remote header tank, thermostat control, pump and fan
assisted. Water and antifreeze mixture...

GENERAL SPECIFICATION DATA
5
INFORMATION AUTOMATIC TRANSMISSION
Automatic gearbox
Model ZF4HP22...............................................................................
Type Four speed and reverse epicylic gears with fluid.................................................................................
torque converter and lock-up
Transfer gearbox
LT230Q Two speed reduction on main gearbox output, front............................................................................
and rear drive...

04GENERAL SPECIFICATION DATA
6
INFORMATION SHIFT SPEEDS - AUTOMATIC ZF
OPERATION SELECTOR VEHICLE SPEED ENGINE SPEED
POSITION APPROX. APPROX. REV/MIN
KICKDOWN (KD)
MPH KPH
KD4 - 3 D 92 - 100 149 - 164
KD3 - 2 3(D) 57 - 62 99 - 108
KD2 - 1 2(D,3) 30 - 37 48 - 61
KD3 - 4 D N/A N/A
KD2 - 3 D(3) 66 - 69 105 - 114 4750 - 5200
KD1 - 2 D(3,2) 37 - 44 61 - 70 4600 - 5250
FULL THROTTLE (FT)
FT4 - 3 D 67 - 73 107 -118
FT3 - 2 3(D) 44 - 53 70 - 80
FT3 - 4 D 81 - 88 130 - 141 3980 - 4330
FT2 - 3 D(3) 60 - 66 96 -...

GENERAL SPECIFICATION DATA
7
INFORMATION STEERING
Power steering box
Make and type Adwest Varamatic - worm and roller box.................................................................
Ratio Variable: straight ahead 19.3:1 to 17.2:1 on lock.................................................................................
Steering wheel turns lock to lock 3.75......................................
Steering pump
Make and type ZF Unicorn....................................................................

04GENERAL SPECIFICATION DATA
8
INFORMATION Shock absorbers
Type Telescopic, double-acting non-adjustable.................................................................................
Bore diameter 35.47mm................................................................... 1.396 in
BRAKES
Front service brake
Caliper AP Lockheed, four opposed pistons..............................................................................
Operation Hydraulic, self...

GENERAL SPECIFICATION DATA
9
INFORMATION AIR CONDITIONING
System CFC free expansion valve system.............................................................................
Compressor Nippon Denso 10PA17.....................................................................
Refrigerant R134a.......................................................................
Charge quantity 900 g±30 g ....................................................... 32 oz±1oz
Refrigerant oil 180...