Land Rover Defender V8i Workshop Supplement Rover Manual

57STEERING
4
REPAIR Refit
15.Clean mating faces of PAS pump and engine.
16.Fit PAS pump and engine lifting bracket to
engine.
17.Fit and tighten bolts securing PAS pump to
engine to
35 Nm (26 lbf.ft).
18.Remove plugs.
19.Connect PAS pipe to pump and tighten union to
20 Nm (15 lbf.ft).
20.Connect PAS hose to pump and secure with clip.
21.Position pulley to PAS pump.
22.Coat threads of PAS pump pulley bolts with
Loctite 242.
23.Restrain pulley using Allen key and tighten bolts
to
10 Nm (7 lbf.ft).
24.Fit...

STEERING
5
REPAIR STEERING LOWER SHAFT
Service repair no - 57.40.25
Remove
1.Set road wheels and steering wheel in straight
ahead position.
2.Loosen clip securing air inlet hose to MAF
sensor.
3.Loosen clip securing air inlet hose to plenum
chamber.
4.Remove air inlet hose.
5.Mark relationship of steering column inner shaft
to top universal joint.
6.Remove 2 bolts from top universal joint.
7.Remove lower bolt from bottom universal joint.
8.Loosen upper bolt from bottom universal joint.
9.Remove steering...

STEERING
1
SPECIFICATIONS, TORQUE TORQUE VALUES
Nm lbf.ft
Drag link to drop arm 40........................................................ 30
Ball joint nuts 40.................................................................... 30
Clamp bolt nuts 14................................................................ 10
Steering column bracket nuts 22........................................... 16
Steering wheel nut 50........................................................... 37
Tie bar to mounting nut -...

70 - BRAKES
CONTENTS
Page
REPAIR
GENERAL BRAKE SERVICE PRACTICE 1...........................................................
FLUID LEVEL CHECK / TOP-UP 1.........................................................................
BRAKE SYSTEM BLEED 2..................................................................................... 

BRAKES
1
REPAIR GENERAL BRAKE SERVICE PRACTICE
Brake fluid precautions
WARNING: Do not allow brake fluid to
come into contact with eyes or skin.
CAUTION: Brake fluid can damage
paintwork, if spilled wash off immediately
with plenty of clean water.
CAUTION: Use only correct grade of brake
fluid. If an assembly fluid is required use
ONLY brake fluid. Do NOT use mineral oil,
i.e. engine oil etc.
CAUTION: Thoroughly clean all brake
calipers, pipes and fittings before
commencing work on any part of the brake...

70BRAKES
2
REPAIR BRAKE SYSTEM BLEED
Service repair no - 70.25.02
Preparation
WARNING: Before bleeding the brake
system refer to general brake service
practice.
See General Brake Service
Practice
·During bleed procedure, brake fluid level must not
be allowed to fall below the MIN level. Keep
reservoir topped up to the MAX level.
·To bleed the hydraulic circuits, four bleed nipples
are provided, one at each caliper.
·There are two methods by which air can be
removed from the braking system:-
1. MANUAL...

76 - CHASSIS AND BODY
CONTENTS
Page
ADJUSTMENT
DOOR LOCK STRIKER - ADJUST 1......................................................................
TAIL DOOR STRIKER - ADJUST 1........................................................................
REPAIR
REAR SEAT BELTS 1.............................................................................................
FRONT SEAT BELTS 2..........................................................................................
SIDE TRIM PANEL...