Juiceman Juice Extractor JM1 User Manual

							Clean Your
Juicer
Thoroughly
Before Retiring
For The DayPLEASE NOTE:CLEANING YOUR JUICER
10 •Unplug from outlet before assembling or removing parts and before
cleaning.
Do not immerse the Motor Base in water or spray it with water. Clean
only by wiping with a damp sponge, cloth, or paper towel. Use any
liquid dishwashing detergent but do not use any products containing
ammonia or scouring powders. These products will dull, scratch or
mar the plastic surface.•All parts (except the Motor Base) are washable in warm, soapy
water. Please follow the procedures outlined in the DISASSEMBLY
INSTRUCTIONS section of this Instruction Manual. To clean the
Juicer Cover and Juice Bowl, we recommend using a fruit and vege-
table brush with natural fibers. 
DO NOT USE A METAL BRUSH OR PAD.
•When cleaning the Blade Basket, use the brush to make sure the
tiny holes in the Basket are not clogged. This can be accomplished
by holding the Blade Basket under a running faucet while brushing
the Basket holes from both inside and outside the Blade Basket.
•Occasionally, the Juice Bowl, Juicer Cover, and Blade Basket may
be washed in a dishwasher, 
only if
they are placed on the 
top shelf
of the dishwasher. However, washing with ordinary warm (not hot)
tap water on a daily basis should be sufficient.
•Sponge off the Motor Base and the legs underneath if any juice has
spilled under the Juicer. Use a damp toothbrush or cloth to clean
juice from inside the Motor Hub on top of the Motor Base.
Juicer should be air-dried only!
Due to the powerful staining properties of the carotenoids that are
found in many vegetables, especially carrots, we suggest the following
cleaning procedures:
•Stained parts may be soaked overnight in 
any 1
of these 4
cleaning solutions: 
(1) biodegradable soap in enough warm water to cover Juicer parts
(2) 1/4 cup bleach to sink full of warm water
(3) 1 part warm water to 1 part cider vinegar
(4) 1/2 small box baking soda in enough warm water to cover parts.
•Never use ammonia or abrasives.
•Lightly scrub with soft bristle brush and  liquid detergent 
after soaking.
•
NEVER SUBMERGE THE MOTOR BASE IN W
ATER OR OTHER LIQUID!
BEFORE FIRST USE The Juiceman® Jr. comes almost completely assembled in the box. We suggest
taking it apart and washing the removable parts in warm water with a biodegrad-
able, non-abrasive liquid detergent before the first use. This will eliminate any
traces of dust or residue from manufacturing or shipping.NOTE: 
Your Juicer may be shipped with a protective cardboard insert between the
Feed Tube and Cutter Blade (on the Blade Basket). Remove this and any other
protective packaging before using your Juicer.
CAUTION: Never rinse or immerse the Motor Base in water or any 
other liquid.
NOTE: 
Refer to the 
Fresh Juice Recipes & Menu Planner
for juice recipes, pulp
recipes, sample menus, and tips on buying, cleaning and storing. 
•Make sure the Blade Basket is securely seated and the Pulp Basket is at the 
rear of the Juicer, ready to catch pulp. To save cleaning time, line the Pulp
Basket with a plastic produce bag (the kind you put your produce in at the
grocery store). 
•Place a glass underneath the Juice Spout.
•Read assembly and disassembly directions. 
Make sure the Juicer is properly and
completely assembled. The Juicer will not turn on unless properly assembled.
PREPARING FRUITS AND VEGETABLES FOR YOUR JUICER•Clean all produce thoroughly, using a natural bristle brush. If you are not using
organic produce, we recommend using a biodegradable cleaner to help remove
pesticide residue.
•Remove and discard the  outer leaves of non-organic produce and peel any
waxed fruit or vegetable.
•Trim away any discolored or bruised sections.
•The skin may be left on all produce (including pineapple and melons) except
oranges, grapefruit, and tangerines. The oil found in these skins tastes bitter and
is difficult to digest.
•Remove melon seeds when possible, as they may escape through the top of the
Feed Tube while juicing. The pits of fruits such as cherries, pears, and peaches
should also be removed.
•Cut produce into pieces small enough to fit into the Feed Tube. Use the Food
Pusher to gently direct produce through the Tube. 
NEVER PUSH PRODUCE
INTO THE FEED TUBE WITH YOUR FINGERS.
•Leafy greens, parsley, wheat grass, and sprouts should be bunched up into a small,
tight ball and pushed through with either a carrot or the Food Pusher.
•Bananas are not suitable for juicing; a clear juice cannot be obtained from them
and residue left in the machine can clog the micro-mesh screen. Produce such as
apricots, plums, pears, peaches, and tomatoes should be firm for best results 
when juicing
.
5     
						

							11
CLEANING YOUR JUICER  
(Continued)
After cleaning and reassembly is complete, your new Juicer is
ready to go to work! Before starting, make sure the Blade
Basket is securely seated and the Pulp Basket is at the rear of
the Juicer to receive pulp. The pulp from your Juicer can be
used in many different applications such as breads, muffins,
cakes, soup stocks, compressed facial packs and garden compost
material. Refer to the 
Fresh Juice Recipes & Menu Planner
for
juice recipes, pulp recipes, sample menus, and tips on buying,
cleaning and storing. Unplug unit and allow to cool. 
Clean the Juicer following the procedures described in this
Instruction Manual. 
Unplug unit and clean before storing. Store in its box 
in a clean, dry place. Never store it while it is hot or still
plugged in. Wrap cord around feet to store. Never wrap cord
tightly around the appliance. Do not put any stress on the cord
where it enters the unit, as it could cause the cord to fray and
break.
Any other
servicing
should be
performed by
authorized
personnel onlySTORAGE
YOUR JUICEMAN
®JR.
CLEAR COVER / WHITE COVER
4
Food Pusher 
(P/N 70094)
Cover JM1 (P/N 70081)
JM1A White Cover
(P/N 70081A)
Stainless Steel 
Blade Basket
(P/N 70082)Juice Bowl    
(P/N 70083)
Motor
BaseMotor
Hub SlotJuice
Spout
ON/OFF
Switch Locking
Clamp
Power
Cord 
with 
Polarized
Plug Pulp Basket
(P/N 70084) Feed Tube
Pulp SpoutMicro-Mesh
Screen
Cutter Blade
Juice Bowl Tabs 
Replacement parts available(except Motor Base).
Call (800) 233-9054
PRODUCT MAY VARY SLIGHTLY FROM
ILLUSTRATIONS®       
						

							TROUBLESHOOTING
Possible CorrectionTry juicing slower, as wet produce is more likely to build up in Cover.
To release pulp, lightly tap on the side of the Cover. Empty Pulp
Basket if full.
Blade Basket may not have been seated correctly, causing it to
become unseated during use. Should this be the case, check  the 
gear teeth of the Blade Basket and the Motor Base for damage. If any
teeth are damaged, call Consumer Service at (800) 233-9054.
Snug seating is desirable. To insert, try seating the Blade Basket 
on a different Hub position. To remove, turn Juice Bowl in a 
clockwise direction.
This may be an isolated situation resulting from the varied texture
and moisture content of the produce. Stop juicing, scrape off pulp
and begin again, alternating types of produce.
Pulp may have built up on the Blade Basket. Clean the Blade Basket
and try alternating different types of produce while juicing. NOTE: 
Because of the Juiceman’s powerful motor, a small amount of
noise and/or vibration is normal when the Juicer is turned on and
as it comes to a complete stop. All Juicers sound slightly different.
Juice the produce as slowly as possible. Keep the Pulp Basket 
emptied for good air flow through machine.
Juice slowly so that the Blade Basket does not full up too quickly 
with juice. Keep Pulp Basket emptied to allow good air flow through
the machine.
Juice slowly to avoid excessive pulp buildup inside the Cover and
Juice Bowl.
SymptomPulp builds up
excessively in 
the back of 
the Juicer Cover.
Bottom of 
Feed Tube is 
damaged.
Blade Basket is
difficult to:
• insert onto 
the Hub;
• remove from
the Hub.
Too much pulp
builds up on
Blade Basket.
Excessive noise or
vibrations occur
after Juicer is 
turned on.
Juice sprays out
of the Spout.
Juice leaks
between Juice
Bowl and Cover.
Pulp in juice.
12
POLARIZED PLUGThis appliance has a polarized plug (one blade is wider than the other). To
reduce the risk of electric shock, this plug is intended to fit into a polarized
outlet only one way. If the plug does not fit fully in the outlet, reverse the
plug. If it still does not fit, contact a qualified electrician. Do not attempt to
modify the plug in any way.SHORT CORD INSTRUCTIONSA short power-supply cord is provided to reduce the risk resulting from
becoming entangled in or tripping over a longer cord.
Do not use an extension cord with this product.ELECTRIC POWERIf the electrical circuit is overloaded with other appliances, your appliance
may not operate properly. It should be operated on a separate electrical
circuit from other appliances.
3     
						

							TROUBLESHOOTING  
(Continued)
Possible CorrectionImproper fit between the Blade Basket and Hub can cause parts of 
the Juice Bowl to rub against the Blade Basket. If this is the case, 
call Consumer Service at (800) 233-9054.
Certain produce (pineapples and overripe produce) may build up on
Blade Basket, causing pulp to eject before juice is completely extracted.
Fruit tends to produce wetter pulp than vegetables. If problem persists,
rinse Blade Basket.
Try a different wall outlet. Also let Juicer sit for about an hour without
turning it on; moisture may have collected on the circuit board,
causing machine to shut OFF. If situation is not resolved, call
Consumer Service at (800) 233-9054.
Try a different wall outlet. Check the Cover, Blade Basket, and Juice
Bowl to see if they are properly seated, and the Locking Clamps are
engaged properly so that the Interlock Switch is activated.
SymptomInside rim of
Juice Bowl is
worn or
chipped (inside
lower rim or
inside upper
rim).
Wet pulp.
Juicer stopped
while juicing.
Juicer does not
turn ON.
13
Additional Important Safeguards
1. All users of this appliance must read and understand this Instruction
Manual before operating or cleaning this appliance.
2. The cord to this appliance should be plugged into a 120V AC electrical
outlet only.
3. Do not leave this appliance unattended during use.
4. If this appliance begins to malfunction during use, immediately press
the ON/OFF Switch down to the OFF position and unplug the cord. Do
not use or attempt to repair the malfunctioning appliance.
5. IF this appliance falls or accidentally becomes immersed in water,
unplug it immediately. 
Do not reach into the water! 
Do not use this
appliance after it has fallen into or becomes immersed in water.
6. To reduce the risk of injury to persons or property, never use this
appliance in an unstable position.
7. Do not use this appliance for other than its intended use.
2     
						

							14
NOTES
IMPORTANT SAFEGUARDS
When using electrical appliances, basic safety precautions should always be
followed including the following:
1. Read all instructions.
2. To protect against risk of electrical shock do not put cord, plugs, or
appliance in water or other liquid.
3. Close supervision is necessary when any appliance is used by or 
near children.
4. Unplug from outlet when not in use, before putting on or taking off
parts, and before cleaning.
5. Avoid contacting moving parts.
6. Do not operate any appliance with a damaged cord or plug or after the
appliance malfunctions, or is dropped or damaged in any manner.
Contact Consumer Service for examination, repair or electrical or
mechanical adjustment.
7. The use of attachments, including canning jars, not recommended by
the manufacturer may cause fire, electric shock, or injury.
8. Do not use outdoors.
9. Do not let cord hang over edge of table or counter.
10. Do not let cord contact hot surface, including the stove.
11. Always make sure Juicer Cover is clamped securely in place before 
motor is turned on. Do not unfasten Locking Clamps while Juicer is 
in operation.
12. Press the ON/OFF Switch down to the OFF position and unplug from
electrical outlet after each use of your Juicer. Make sure the Motor is
completely stopped before disassembling.
13. Do not put your fingers or other objects into the Juicer opening while it
is in operation. If food becomes lodged in opening, use Food Pusher or
another piece of fruit or vegetable to push it down. When this method
is not possible, press the ON/OFF Switch down to the OFF position,
unplug Juicer from electrical outlet, and disassemble Juicer to remove
remaining food.
SAVE THESE INSTRUCTIONS
FOR HOUSEHOLD USE ONLY
1     
						

							LIMITED ONE YEAR WARRANTY
Warranty:
This Juiceman® product is warranted by Salton, Inc. to be free from defects in materials or
workmanship for a period of (1) year from the original purchase date. This product warranty covers only the
original consumer purchaser of the product.
Warranty Coverage:
This warranty is void if the product has been damaged by accident in shipment,
unreasonable use, misuse, neglect, improper service, commercial use, repairs by unauthorized personnel,
normal wear and tear, improper assembly, installation or maintenance abuse or other causes not arising out
of defects in materials or workmanship. This warranty is effective only if the product is purchased and
operated in the USA, and does not extend to any units which have been used in violation of written
instructions furnished with the product or to units which have been altered or modified or to damage to
products or parts thereof which have had the serial number removed, altered, defaced or rendered illegible.
Implied Warranties:
ANY IMPLIED WARRANTIES WHICH THE PURCHASER MAY HAVE ARE LIMITED IN
DURATION TO ONE (1) YEAR FROM THE DATE OF PURCHASE. Some states do not allow limitations on how
long an implied warranty lasts, so the above limitation may not apply to you.
Warranty Performance: 
During the above one-year warranty period, a product with a defect will be
either repaired or replaced with a reconditioned comparable model (at our option) when the product is
returned to the Repair Center, or the purchase price refunded. The repaired or replacement product will be
in warranty for the balance of the one-year warranty period and an additional one-month period. No charge
will be made for such repair or replacement.
Service and Repair: 
Should the appliance malfunction, you should first call toll-free 1 (800) 233-9054
between the hours of 9:00 am and 5:00 pm Central Standard Time and ask for CONSUMER SERVICE stating
that you are a consumer with a problem. Please refer to model number JM1 or JM1A when you call.
In-Warranty Service (USA): 
For an appliance covered under the warranty period, no charge is made for
service or postage. Call for return authorization 1 (800) 233-9054.
Out-of Warranty Service:  
A flat rate charge by model is made for out-of-warranty service. Include
$15.00 (U.S.) for return shipping and handling. We will notify you by mail of the amount of the charge for
service and require you to pay in advance for the repair or replacement.
For Products Purchased in the USA, but Used in Canada:  
You may return the product insured,
packaged with sufficient protection, and postage and insurance prepaid to the USA address listed below.
Please note that all customs duty / brokerage fees, if any, must be paid by you and we will require you to pay
the cost of customs duty / brokerage fees to us in advance of our performing any service.
Risk During Shipment: 
We cannot assume responsibility for loss or damage during incoming shipment.
For your protection, carefully package the product for shipment and insure it with the carrier. Be sure to
enclose the following items with your appliance: any accessories related to your problem, your full return
address and daytime phone number, a note describing the problem you experienced, a copy of your sales
receipt or other proof of purchase to determine warranty status. C.O.D. shipments cannot be accepted.
To return the appliance, 
ship to:
To contact us, 
please write to, call, or email: 
ATTN: Repair Center Salton, Inc.
Salton, Inc. P.O. Box 7366
708 South Missouri Street Columbia, MO  65205-7366
Macon, MO  63552 1-800-233-9054
E-mail: [email protected]
Limitation of Remedies:
No representative or person is authorized to assume for Salton, Inc. any other
liability in connection with the sale of our products. There shall be no claims for defects or failure of
performance or product failure under any theory of tort, contract or commercial law including, but not limited to
negligence, gross negligence, strict liability, breach of warranty and breach of contract. Repair, replacement or
refund shall be the sole remedy of the purchaser under this warranty, and 
in no event shall Salton be
liable for any incidental or consequential damages, losses or expenses. 
Some states do not allow
the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not
apply to you.
Legal Rights:  
This warranty gives you specific legal rights, and you may also have other rights which vary
from state to state.
For more information on Salton products: visit our website: www
.eSalton.com
, or email us at:
[email protected]
©2004 Salton, Inc.  All rights reserved. P/N 60740
Printed in Korea 02/04
INSTRUCTION
M
ANUAL
MODELS
: JM1, JM1A®