IBM Thinkpad R32 Manual

CDC card.
Note:When you install the PCI card, remember to insert it
into its socket at 20°, press it down and ensure the
connection is well.
1030 Memory cover and Memory card
Disassembly
v“1010 Battery Disassembly”on page 63
1
2
MT 2658/2659/267765 

Note:The screws do not separate from the memory
cover.
1
2
To install the memory card:
With the notched end of the memory card toward the right
side of the socket, insert the memory card, at an angle of
approximately 20°, into the socket; then press it firmly.
Pivot the memory card until it snaps into place.
Side View
1040 Hard Disk Drive Disassembly
v“1010 Battery Disassembly”on page 63
66ThinkPad R32 Series 

1
2
Step Size (Quantity) Color Torque
1 M3 x L3.5 (1) Black 3.2 kgf-cm
WarningDo not drop or apply any shock to the hard disk
drive. The hard disk drive is sensitive to physical
shock. Incorrect handling can cause damage and
permanent loss of data on the drive.
Before removing the drive, have the user make a
backup copy of all the information on the drive if
possible.
Never remove the drive while the system is
operating or is in suspend mode.
1050 Hard Disk Drive Cover Disassembly
v“1010 Battery...

1
2
3
1070 Keyboard Disassembly
v“1010 Battery Disassembly”on page 63
1a1b
Step Size (Quantity) Color Torque
1 M2.5 x L10 (2) Black 3.2 kgf-cm
68ThinkPad R32 Series 

2
3
4
Notes:
1. When replacing the keyboard, make sure that the cable
is clean and insert it directly into the connector, making
sure it makes contact with the bottom of the connector.
2. If the cable do not touch the bottom of the connector,
the keyboard function will be rendered useless.
3. The cable of the keyboard are fragile and could be
damaged. Be careful when pulling out the cable.
1080 Backup Battery Disassembly
v“1010 Battery Disassembly”on page 63
v“1070 Keyboard Disassembly”on page 68
MT...

1
2
CAUTION:
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type
recommended by the manufacturer. Dispose of used
batteries according to manufacturer’s instruction.
Safety Notice 4Translation in″Safety Notices: Multi-lingual
Translations″section: The backup battery is a
lithium battery and can cause a fire, an explosion, or
severe burns. Do not recharge it, remove its
polarized connector, disassemble it, heat it above
100°C (212°F), incinerate it, or...

1
1100 Middle Cover Disassembly
v“1010 Battery Disassembly”on page 63
v“1070 Keyboard Disassembly”on page 68
1
2
MT 2658/2659/267771 

4
Step Size (Quantity) Color Torque
2 M2.5 x L10 (1) Black 3.2 kgf-cm
4 M2.5 x L5 (1) Silver 2.5 kgf-cm
1110 CDC Cover Disassembly
v“1010 Battery Disassembly”on page 63
v“1020 Mini-PCI cover and Mini-PCI card Disassembly”
on page 64
v“1070 Keyboard Disassembly”on page 68
v“1100 Middle Cover Disassembly”on page 71
1
Step Size (Quantity) Color Torque
1 M2.5 x L5 (1) Silver 2.5 kgf-cm
72ThinkPad R32 Series 

2
3
Notes:
1. If the Thinkpad R32 products are equipped with the
Mini-PCI card, then the CDC modem card will not be
installed. The procedure of″cdc-card″referred above
should be skipped.
1120 Modem Cable Disassembly (Without
CDC Modem Card)
v“1010 Battery Disassembly”on page 63
v“1020 Mini-PCI cover and Mini-PCI card Disassembly”
on page 64
v“1070 Keyboard Disassembly”on page 68
v“1100 Middle Cover Disassembly”on page 71
v“1110 CDC Cover Disassembly”on page 72
1
2
Notes:
1. If the Thinkpad R32 products...

installed. The modem cable will then be connected to
the Mini-PCI card. Refer to″Mini-PCI card″
disassembly procedure to disconnect the modem
cable.
1130 Modem Cable Disassembly (With CDC
Modem Card)
v“1010 Battery Disassembly”on page 63
v“1070 Keyboard Disassembly”on page 68
v“1100 Middle Cover Disassembly”on page 71
v“1110 CDC Cover Disassembly”on page 72
1
Notes:
1. If the Thinkpad R32 products are equipped with the
CDC modem card, the wireless LAN board will not be
installed. The modem cable will...