Dell E6530 Service Manual

							Back to Contents Page    
I/O Board  
 
Removing the I/O Board  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .   
3. Remove the  access panel .   
4. Remove the  subscriber identity module (SIM) card .   
5. Remove the  optical drive .   
6. Remove the  keyboard .   
7. Remove the  coin - cell battery .   
8. Remove the  hinge covers .   
9. Remove the  display assembly .   
10. Remove the  hard drive .   
11. Remove the  Latitude ON™ flash card .   
12. Remove the  wireless wide area network (WWAN) card .   
13. Remove the  wireless local area network (WLAN) card .   
14. Remove the  heat sink and fan assembly .   
15. Remove the  processor .   
16. Remove the  palm rest assembly .   
17. Remove the  Bluetooth ®  card .   
18. Remove the  ExpressCard board .   
19. Remove the  system board .   
20. Remove the screw (labeled I) that secures the I/O board to the computer. 
   
21. Remove the screws that secure the I/O board to the computer. 
   
22. Remove the I/O board from the computer. 
   
Replacing the I/O Board  
To replace the I/O board, perform the above steps in reverse order.  
Back to Contents Page    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Keyboard  
 
Removing the Keyboard  
   
1. Follow the procedures in  Before Working Inside Your Computer .  
2. Remove the  battery .   
3. Remove the  LED cover .   
4. Remove the screws along the top of the keyboard. 
 
5. Using the pull tab, gently lift the keyboard at an angle and slide it out of the computer. 
   
Replacing the Keyboard  
To replace the keyboard, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe Flash Player from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Latitude ON Flash Card  
 
Removing the Latitude ON Flash Card  
   
1. Follow the procedures in  Before Working Inside Your Computer .  
2. Remove the  battery .   
3. Remove the  access panel .   
4. Remove the screw that secures the Latitude ON™ Flash card to the system board. 
   
5. Slide the Latitude ON Flash card out of its connector on the system board. 
   
Replacing the Latitude ON Flash Card  
To replace the Latitude ON Flash card, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Display Assembly  
 
Removing the Display Assembly  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .   
3. Remove the  access panel .   
4. Remove the  hinge covers.    
5. Loosen the captive screws that secure the display cable to the system board and disconnect the display cable from its connector on the system board. 
   
6. Disconnect and release the antenna cables from wireless local area network (WLAN) card. 
   
7. Remove the screws that secure the display assembly to the computer. 
   
8. Disconnect and release the antenna cables from wireless wide area network (WWAN) card. 
   
9. Remove the screws that secure the display assembly to the computer. 
   
10. Lift the display assembly up and away from the computer. 
   
Replacing the Display Assembly  
To replace the display assembly, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Display Bezel  
 
Removing the Display Bezel  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .  
3. Remove the  access panel .  
4. Remove the  hinge covers .  
5. Remove the  display assembly .   
6. Starting from the bottom, gently pry the bezel inside out from the display assembly.
   
7. Remove the bezel from the display assembly. 
   
Replacing the Display Bezel  
To replace the display bezel, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Display Cover  
 
Removing the Display Cover  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery.    
3. Remove the  access panel .   
4. Remove the  hinge covers .   
5. Remove the  display assembly .   
6. Remove the  display bezel .   
7. Remove the  display panel .   
8. Remove the  camera and microphone .   
Replacing the Display Cover  
To replace the display cover, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Hinge Covers  
 
Removing the Hinge Covers  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .  
3. Remove the  access panel .   
4. Remove the screws that secure the right hinge cover to the computer. 
   
5. Remove the screws that secure the left hinge cover to the computer. 
   
6. Slide the left and right hinge covers toward the back of the computer and remove them from the computer. 
   
Replacing the Hinge Covers  
To replace the hinge covers, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Display Hook  
 
Removing the Display Hook(s)  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .  
3. Remove the  display bezel    
4. Remove the screw that secures the display hook to the display panel.. 
   
5. Remove the display hook from the display panel. 
   
6. Remove the screw that secures the display hook to the display panel. 
   
7. Remove the display hook from the display panel. 
   
Replacing the Display Hook  
To replace the display hook(s), perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
Display Panel  
 
Removing the Display Panel  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .  
3. Remove the  access panel .  
4. Remove the  hinge covers .  
5. Remove the  display assembly .  
6. Remove the  display bezel .   
7. Remove the screws that secure the display panel to the display assembly.
   
8. Lift the display panel and gently lay it on a flat clean surface.  
9. Disconnect the display cable from the display panel. 
   
10. Remove the display panel from the display assembly. 
   
11. Remove the screws on either sides of the display panel, to release the display brackets.
   
12. Remove the display brackets from the display panel. 
   
Replacing the Display Panel  
To replace the display panel, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.    
						

							Back to Contents Page    
LED Cover  
 
Removing the LED Cover  
   
1. Follow the procedures in  Before Working Inside Your Computer .   
2. Remove the  battery .   
3. Press in on the LED cover release latches in the battery bay.   
   
4. Turn the computer over, with the right side facing up and remove the LED cover from the computer.   
 
Replacing the LED Cover  
To replace the LED cover, perform the above steps in reverse order.  
Back to Contents Page    
   
    WARNING:  Before working inside your computer, read the safety information that shipped with your computer. For additional safety best 
practices information, see the Regulatory Compliance Homepage at www.dell.com/regulatory_compliance. 
NOTE:   You may need to install Adobe™ Flash Player™ from  Adobe.com  in order to view the illustrations below.