Bissell 58f83 Manual

							Checking rotating f\boor brush and drive be\bt continued
11w w w . b i s s e l l . c o m 	8 0 0 . 2 3 7 . 7 6 9 1
Maintenance and car\Ve 
 
6. Clean strings, hair and other debris from 
motor pulley and drive belt areas.
7.  Chec\f drive belt carefully for wear, cuts or 
stressed areas.
8.  Chec\f air passageway for obstructions. 
Remove debris from this area.
Rep\bace drive be\bt
U\be only genuine  bISSE ll \btyle 9 replacement 
belt\b (#32074) in your  bISSE ll vacuum.
1.  Turn power off. Unplug cleaner from electri-
cal outlet.
2.  With rotating floor brush removed from 
vacuum cleaner (steps 1-4 of Chec\f rotating 
floor brush and drive belt), grasp old drive 
belt and remove from motor pulley. Discard 
old drive belt.
3.  Place new drive belt over motor pulley and 
stretch other end over rotating floor brush in 
the space between the bristles.
4.  Place ends of rotating floor brush down into 
slots on sides as shown.
5.  Turn rotating floor brush by hand several 
times in the direction of motor pulley. If 
properly installed, drive belt will center itself 
on rotating brush.
6.  Reposition brush cover and screw bac\f into 
place. 
Air Passageway
Motor   
Pulley
8.
4. 
						

							12w w w . b i s s e l l . c o m 	8 0 0 . 2 3 7 . 7 6 9 1
Maintenance and car\Ve 
C\beaning a c\bog
low \buction or poor pickup may be due to a clog 
in t\fe vacuum cleaner.  If you notice a c\fange 
in t\fe \bound of t\fe motor or a reduction in t\fe 
\bpinning action, c\feck for clog\b.
1.  Unplug cleaner from electrical outlet.
2.  Empty dirt container.
3.  Chec\f upper tan\f for build up or clogs.  
4.  Chec\f the suction inlet for a clog.
5.  Grasp the quic\f reach handle and lift hose 
wand to separate from the suction opening.  
Chec\f for a clog in the base, the wand or   
the hose.
6.  Remove the screw attaching the hose wand 
base to the vacuum. \btraighten the hose 
wand base and unclog with long, narrow 
object such as a broom stic\f.
7.  If the clog persists, follow the instructions 
for chec\fing the rotating floor brush on 
page 11 and inspect the air passageway for 
obstructions.
Rep\bace \bight bu\bb
U\be only  bISSE ll Replacement  bulb\b in your 
b ISSE ll vacuum.
1.  Unplug cleaner from electrical outlet
2.  Using a flat screwdriver, table \fnife or coin, 
insert into the slot on the right of the lens 
and gently push inner latch to the left as 
shown to remove the lens.
3.  Reposition lens by inserting the tab on left 
side and then pushing the right side bac\f 
into place.
3.
4.
6.
2.3.
Suction 
inlet 
						

							13w w w . b i s s e l l . c o m 	8 0 0 . 2 3 7 . 7 6 9 1
Troub\beshooting
Vacuum cleaner won’t turn on
Po\b\bible cau\be\b  Remedie\b
1.  Power cord not plugged in   1.  Chec\f electrical plug
2.   Blown fuse/tripped brea\fer   2.  Chec\f/replace fuse or reset brea\fer
3.   Damaged cord   3.  Refer to a BI\b\bELL authorize service center 
    for repair or replacement
Vacuum cleaner won’t pick up dirt
Po\b\bible cau\be\b    Remedie\b
1.  Incorrect height adjustment   1. Adjust powerfoot to correct height setting
2.   Hose not attached to suction opening   2. Grasp quic\f reach handle and firmly push
     hose wand onto the suction opening
3.   Crac\f or hole in hose   3. Chec\f hose and replace if needed
4.   Bro\fen or worn drive belt   4. Replace drive belt, see page 11
5.   Rotating floor brush bristles worn  5. Replace brush
6.   Rotating floor brush jammed   6. Remove brush and clean debris from brush ends
7.   Clog in vacuum   7. Follow instructions on page 12 for clearing clogs
8.   Dirt container full   8. Empty dirt container
9.   Dirt container or upper tan\f not installed properly  9. Position correctly and loc\f in place
10.  Filters are dirty   10. Chec\f and clean pre-motor and HEPA media
      post-motor filters, see page 9
tool\b won't pick up dirt
Po\b\bible cau\be\b   Remedie\b
1.  Crac\f or hole in hose   1.  Chec\f hose and replace if needed
2.   Clog in vacuum   2.  Follow instructions on page 12 for clearing clogs
3.   Dirt container full   3.  Empty dirt container
4.   Dirt container or upper tan\f not installed properly  4.  Position correctly and loc\f in place
5.   Filters are dirty   5.  Chec\f and clean pre-motor and 
      post-motor filters 
						

							14w w w . b i s s e l l . c o m 	8 0 0 . 2 3 7 . 7 6 9 1
BISSELL Consumer Ser\Vvices
For in\formation about repairs or replacement parts, or questions about your warranty, call:
bISSEll con\bumer Service\b 
1-800-237-7691
 
Monday - Friday    8 a\bm\b — 10 p\bm\b EST
Saturday    9 a\bm\b — 8 p\bm\b EST
Or write:
BISSELL HOMECARE, INC
PO Box 3606
Grand Rapids  MI 49501
ATTN: Consumer Services
 
Or visit the BISSELL website -  www.bi\b\bell.com
When contacting BISSELL, have model number o\f unit available\b
Please record your Model Number: __________________\(_
Please record your Purchase Date:  __________________\(_
notE: Plea\be keep your original \bale\b receipt. It provide\b proof of date of purc\fa\be in t\fe event 
of a warranty claim. See Warranty on page 16 for detail\b.  
Plea\be regi\bter your new bISSEll product at  
www.bissell.com/productregistration\f
Troub\beshooting
Vi\bible dirt e\bcaping from cleaner
Po\b\bible cau\be\b   Remedie\b
1.  Dirt container full   1.  Empty dirt container
2.   Filters missing or installed incorrectly  2.  Chec\f pre-motor and post-motor 
      filters for correct installation
cord will not retract
Po\b\bible cau\be\b   Remedie\b
1.  Knotted or twisted   1.  Follow instructions on page 8
ot\fer maintenance or \bervice not included in t\fe manual \b\fould be performed by an   
aut\forized \bervice repre\bentative.
t \fank you for \belecting a  bISSE ll product.
Plea\be do not return t\fi\b product to t\fe \btore.          
   
For any que\btion\b or concern\b,  bISSE ll i\b \fappy to be of \bervice.   
c ontact u\b directly at 1-800-237-7691. 
						

							2
2
15w w w . b i s s e l l . c o m 	8 0 0 . 2 3 7 . 7 6 9 1
Rep\bacement parts
Accessories
you may purchase replacement parts from your retailer, by calling BI\b\bELL Consumer \bervices or by vis -
iting our website. To locate a retailer near you, or to place an order using  visa,  masterCard, Discover or 
American Express, call
bISSEll  con\bumer Service\b
1-800-237-7691 Monday - Friday  8 a.m. — 10 p.m. E\f
Saturday  \b a.m. — 8 p.m. E\f
Or visit our Website -  www.bi\b\bell.com 
Item Part no.  Part name
 1    32074  Style \b Drive Belt (2-Pack)
 2    203-12\b7  Standard Headlight Bulb 
 3    203-2450  Hose Assembly (Rewind PowerClean)
 4    203-2468  Hose Assembly (Rewind SmartClean)
 5    203-244\b  Brush Dowel (15")
 6    32R\b   Style 16 Inner and Outer Circular Pre-Motor Filter Set
 7    73K1   Style 16 Inner Circular Pre-Motor Filter
 8    6\bB1  Style 16 Outer Circular Pre-Motor Filter
 \b    32076  Style 7/\b/16 Post-Motor HEPA Media Filter 
 
10  203-1215  Style 7/\b/16 Pre-Motor Filter
t\fe\be item\b are available for purc\fa\be a\b acce\b\borie\b for your  bISSE ll Rewind Smart clean/
Rewind Power clean:   
t o purc\fa\be call 1-800-237-7691 or vi\bit www.bi\b\bell.com. 
Item  Part no.  Part name
 1    203-2447  \furboBrush
 2    203-1063  Crevice \fool
 3    203-10\b\b  Combination Dusting/Upholstery Brush
 4    203-1084  Extension Wand 
1
1
78
3/4
3
9
5
4
10
6 
						

							16w w w . b i s s e l l . c o m
Warranty - BISSELL Re\find SmartC\bean & Re\find Po\ferC\bean
 This warranty gives you speci\fic legal rights, and you may also have other rights which may vary \from state to state\b 
I\f you need additional instruction regarding this warranty or have questions regarding what it may cover, please con-
tact BISSELL Consumer Services by E-mail, telephone, or regular mail as described below\b
limited t\free year Warranty
 Subject to the  *EXcEPtIonS  anD EXclUSIonS identi\fied below, upon receipt o\f the product BISSELL 
Homecare, Inc\b will repair or replace (with new or remanu\factured components or products), at BISSELL’s option, 
\free o\f charge \from the date o\f purchase by the original purchaser, \for three years any de\fective or   
mal\functioning part\b
 See in\formation below on "I\f your BISSELL product should require service"\b
 This warranty applies to product used \for personal, and not commercial or rental service\b This warranty does not apply to 
\fans or routine maintenance components such as \filters, belts, or brushes\b Damage or mal\function caused by negligence, 
abuse, neglect, unauthorized repair, or any other use not in accordance with the User's Guide is   
not covered\b
 
If your  bISSE ll product \b\fould require \bervice:
Contact BI\b\bELL Consumer \bervices to locate a BI\b\bELL Authorized \bervice Center in your area. 
If you need information about repairs or replacement parts, or if you have questions about your warranty, 
contact BI\b\bELL Consumer \bervices.
Web\bite or E-mail:
www.bissell.com 
Use the “Customer \bervices” tab.
or  call: 
BI\b\bELL Consumer \bervices 
1-800-237-7691 
m onday - Friday 8 a.m. - 10 p.m. ET 
\baturday 9 a.m. - 8 p.m. ET 
o r Write:
BI\b\bELL Homecare, Inc.  
P o  Box 3606 
Grand Rapids,  mI 49501 
ATT n: Consumer \bervices
bISSEll  hoMEcaRE, Inc. IS  not lIablE FoR IncIDEntal  oR conSEQUEntIal D aMaGES oF any  natURE 
aSSocIatED WIth  thE USE oF thIS PRoDUct . bISSEll ’S lIabIlIty WIll  not EXcEED thE PURchaSE PRIcE 
oF  thE PRoDUct .
 
Some \btate\b do not allow t\fe exclu\bion or limitation of incidental or con\bequential damage\b, \bo t\fe above 
limitation or exclu\bion may not apply to you. 
*EXcEPtIonS  anD EXclUSIonS FRoM  thE tERMS  oF thE  lIMItED  WaRRanty
THIS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES EITHER   
ORAL OR WRITTEN\b ANY IMPLIED WARRANTIES WHICH MAY ARISE BY OPERATION   
OF LAW, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND   
FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE WARRANTY DURATION   
FROM THE DATE OF PURCHASE AS DESCRIBED ABOVE\b
Some states do not allow limitations on how long an implied warranty last so the   
above limitation may not apply to you\b
©2010 BISSELL Homecare, Inc
Grand Rapids, Michigan
All rights reserved\b Printed in Korea
Part Number 110-4190
Rev 02/10
Visit our website at:
www\bbissell\bcom