Apple ibook g4 14 inch late 2004 User Manual

 
iBook G4 (14-inch Late 2004) Take Apart -   
150  
 Reed Switch Board4.
  Warning:
   
  When removing the tape that bundles the reed switch cable assembly 
to the AirPort antenna cable, be careful not to strain or pinch the cables.
Replacement Note:
  When installing the replacement reed switch board and cables, 
use new tape to bundle the cables together. 
Remove the tape to free the AirPort antenna cable from the reed switch cable 
assembly   
5. Disconnect the data cable from the inverter board at...

 
151 -  
iBook G4 (14-inch Late 2004) Take Apart
 Reed Switch Board 6. Remove the reed switch cable assembly.
7. Install the replacement reed switch board and cable assembly, and reassemble and 
test the computer. 

 
iBook G4 (14-inch Late 2004) Take Apart -   
152  
 Microphone Cable  Microphone Cable  Tools 
• Soft cloth
• Black stick (or other nonconductive nylon or plastic tool) 
Replacement Note: 
 If the tape you remove from this assembly is worn and cannot be 
reused, use new Kapton tape (Apple part number 922-5025). 
Preliminary Steps 
Before you begin, remove the following:
• Battery 
• Keyboard and RAM shield
• AirPort Extreme Card
• Memory card
• Bottom case
• Bottom shield
• DC-in board
• Top case
• Top...

 
153 -  
iBook G4 (14-inch Late 2004) Take Apart
 Microphone Cable  Procedure  Note:
   Although your bezel assembly might appear somewhat different than shown, the 
steps to follow are the same. 
  Warning:
   
  Be careful not to strain or pinch the delicate microphone cable or 
surrounding cables when performing this procedure.
  1. With the bezel assembly lying on a soft cloth, use a black stick to loosen the slack on 
the cable near the microphone gasket.
2. Pry up the microphone gasket from the...

 
iBook G4 (14-inch Late 2004) Take Apart -   
154  
 Microphone Cable4. Free the microphone cable from the right corner of the bezel and from underneath the 
tape at the antenna board.  

 
155 -  
iBook G4 (14-inch Late 2004) Take Apart
 Microphone Cable 5.
  Warning:
   
  When removing the tape and spiral tube that bundles the microphone 
cable to the LCD cable, be careful not to strain or pinch the cables.
Replacement Note:
   When installing the replacement microphone cable, reuse the 
spiral tube to bundle the microphone cable to the LCD cable. However, use new tape 
when bundling the cables together. 
Separate the microphone cable from the LCD cable by removing the tape, and...

 
iBook G4 (14-inch Late 2004) Take Apart -  
156  
 Bezel Brace with Clutch Assembly  Bezel Brace with Clutch 
Assembly  Tools 
• Soft cloth
• #0 Phillips screwdriver 
Replacement Note: 
 If the tape you remove from this assembly is worn and cannot be 
reused, use new Kapton tape (Apple part number 922-5025). 
Preliminary Steps 
Before you begin, remove the following:
• Battery 
• Keyboard and RAM shield
• AirPort Extreme Card
• Memory card
• Bottom case
• Bottom shield
• DC-in board
• Top case
• Top...

 
157 -  
iBook G4 (14-inch Late 2004) Take Apart
 Bezel Brace with Clutch Assembly  Procedure  Note:
   Although your bezel assembly might appear somewhat different than shown, the 
steps to follow are the same. 
1. With the bezel assembly lying on a soft cloth, remove the three pieces of tape. 
2. Remove the two 5- mm long Phillips screws at the left bezel brace. 
3. At the right bezel brace, remove the two Phillips screws:
• one 5-mm long screw near the top of the right brace
• one 3-mm long screw...

 
iBook G4 (14-inch Late 2004) Take Apart -  
158  
 Bezel Brace with Clutch Assembly5. Lift the 3-sided bezel brace with clutch assembly off of the bezel.   
6. Install the replacement bezel brace with clutch assembly, and reassemble and test the 
computer. 

 

© 2004 Apple Computer, Inc. All rights reserved.
 

 
 
 
Service Source
Troubleshooting
 
iBook G4 (14-inch Late 2004)