AirComm Corporation Airbus EC130 Cabin Air Conditioner Instructions for Continued Airworthiness User Manual

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 4 
12. CHANGES TO INSTRUCTIONS FOR CONTINUED AIRWORTHINESS 
Changes made to a line or paragraph of this document will be indicated by a vertical bar 
in the right hand margin, while a complete page change will be indicated by a vertical 
bar next to the page number. 
 
 
(Example: Any change will appear with a vertical bar next to that...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 5 
 
Forward Evaporator optional 
 
 
             
 
COCKPIT A/C CONTROL PANEL 
  
 
The Fan motors feature dual speed operation (Hi or Lo), and this feature can be used in 
both the air conditioner or fan modes. 
 
The compressor is mounted to the surface of the Main Gearbox (MGB) Coupling Case, 
in the aft aircraft center portion of the...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 6 
 
 
The switch operating pressures are: 
 
Low Pressure Function: 
Open at 28 ± 2.8 psig (2.0 ± 0.2 Kg/Cm)  
Close at 30 ± 4.3psig (2.1 ± 0.3 Kg/Cm)  
 
High Pressure Function: 
Open at 384 ± 30 psig (28.0 ± 2.0 Kg/Cm)  
Close at 298 ± 43 psig (20.9 ± 2.0 Kg/Cm) 
 
An optional Auxiliary Ventilation system may be installed to provide...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 7 
 
 
                   
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
  
 
      High pressure liquid 
      High pressure vapor 
      Low pressure liquid 
      Low pressure vapor 
      Expansion valve        
       By pass line 
 
 
Fig 1.1 Refrigeration Cycle Functional Schematic 
 
 
 
 
 
 
 
 
 
Receiver-Dryer 
Forward 
Evaporator...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 8 
 
CHAPTER 2 
AIRWORTHINESS LIMITATION SECTION 
 
1. AIRWORTHINESS LIMITATIONS  
 
“No airworthiness limitations associated with this type design change” 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
 
  

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 9 
CHAPTER 3 
 INSPECTIONS 
 
1. INSPECTION REQUIREMENTS 
 
PERIODIC INSPECTIONS  
 
Item Annual Every 25 Hours of  Operation Every 100 Hours of Operation Special Inspection Information Evaporator Blower Hi/Lo Operation  X   X Check for operation 
Condenser Blower Motor, Scoop Door Actuator 
 X    X Check for operation 
Forward & Aft...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 10 
Note that the evaporator blowers have an additional connector to inspect located several 
inches away from the harness connector.  
NOTE: Aft evaporators supplied in late 2014 and newer use a gray plastic Deutsch 
connector and are not part of this inspection requirement. 
b) De-mate each connector and inspect both mates for signs of...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 11 
CHAPTER 4 
LOCATION AND ACCESS 
 
1. LOCATION OF AIR CONDITIONER FEATURES 
 
Nomenclature Description of Location 
Air Conditioner Control Panel The air conditioner control panel is located in the existing center overhead panel between the pilot & co-pilot seats.  
Optional Forward (Cockpit) Evaporator The forward evaporator is mounted...

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 12 
 
2. LAYOUT OF AIR CONDITIONER SYSTEM  
 
Fig. 4-2 Top View - Model C130B Fuselage, EC130-200-1,-2 Install 
   

 
AIR CONDITIONER SERVICE MANUAL EC130-200M-1 
Revision 6                                                                                                         Page 13 
 
3. LAYOUT OF AIR CONDITIONER SYSTEM 
 
Fig. 4-3 Side View - Model EC130B Fuselage- Baggage area Condenser Installation-  
EC130-202-1 (Shown), -2 Install (opposite)