Acer Aspire 9510 Service Guide

							95Chapter 4
The system doesnt resume from hibernation/ 
standby mode.Connect AC adapter then check if the system resumes from 
Standby/Hibernation mode. 
Check if the battery is low.
Hard disk drive
Main board
The system doesnt resume from standby mode 
after opening the lid of the portable computer.LCD cover switch
Main board
Battery fuel gauge in Windows doesn’t go higher 
than 90%. Refresh battery (continue use battery until power off, then charge 
battery).
Battery pack
Main board
System hangs intermittently. Reconnect hard disk/CD-ROM drives. 
Main board
Peripheral-Related Symptoms
Symptom / ErrorAction in Sequence
System configuration does not match the 
installed devices. Enter BIOS Setup Utility to execute “Load Setup defaults”, then 
reboot system.
Reconnect hard disk/CD-ROM drives/FDD or other peripherals.
Main board
External display does not work correctly. Press Fn+F5, LCD/CRT/Both display switching
Keyboard
Main board
USB does not work correctly Main board
Print problems. Enter BIOS Setup Utility to execute “Load Default Settings” then 
reboot the system.
Run printer self-test.
Printer driver
Printer cable
Printer
Main board
Parallel port device problems Enter BIOS Setup Utility to execute “Load Default Settings” then 
reboot the system.
Device driver
Device cable
Device
Main board
Keyboard/Touchpad-Related Symptoms
Symptom / ErrorAction in Sequence
Keyboard (one or more keys) does not work. Reconnect the keyboard cable.
Keyboard
Main board
Touchpad does not work. Reconnect touchpad cable.
Touchpad board
Main board
Power Management-Related Symptoms
Symptom / ErrorAction in Sequence 
						

							Chapter 496
NOTE: If you cannot find a symptom or an error in this list and the problem remains, see “Undetermined 
Problems” on page 98. Modem/LAN-Related Symptoms
Symptom / ErrorAction in Sequence
Internal modem does not work correctly. Phone cable
Driver
Reconnect the Internal modem cable to the main board tightly.
Main board
Internal LAN does not work correctly Lan cable
Driver
Main board 
						

							97Chapter 4
Intermittent Problems
Intermittent system hang problems can be caused by a variety of reasons that have nothing to do with a 
hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. FRU replacement 
should be considered only when a recurring problem exists.
When analyzing an intermittent problem, do the following:
1.Run the diagnostic test for the system board in loop mode at least 10 times.
2.If no error is detected, do not replace any FRU.
3.If any error is detected, replace the FRU.  Rerun the test to verify that there are no more errors.  
						

							Chapter 498
Undetermined Problems
The diagnostic problems does not identify which adapter or device failed, which installed devices are incorrect, 
whether a short circuit is suspected, or whether the system is inoperative.  
Follow these procedures to isolate the failing FRU (do not isolate non-defective FRU).
NOTE: Verify that all attached devices are supported by the computer.
NOTE: Verify that the power supply being used at the time of the failure is operating correctly. (See “Power 
System Check” on page 84):
1.Power-off the computer.
2.Visually check them for damage. If any problems are found, replace the FRU.
3.Remove or disconnect all of the following devices:
TNon-Acer devices
TPrinter, mouse, and other external devices
TBattery pack
THard disk drive
TDIMM 
TPC Cards
4.Power-on the computer.
5.Determine if the problem has changed.
6.If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU.
7.If the problem remains, replace the following FRU one at a time. Do not replace a non-defective FRU:
TSystem board
TLCD assembly 
						

							Chapter 599
Mainboard Layout
Jumper and Connector Locations
Chapter 5 
						

							100Chapter 5
Switching Setting
SwitchFunction
SW6-1 CHK_PW&#
SW6-2 No function
SW1-3 MATRIXID 1#
SW1-4 MATRIXID 2#
MATRIXID1# 33
3D3V_S0
MATRIXID2# 33
1234
5678
SW 6
SW -D IP-4-2-U 2-GP
DY
21
G3 GAP-OPEN
C HK_PW# 16
12
34
RN16 SR N10KJ -5-GP
1
2
EC 20
SC 1000P50V3J N-GPDY
PH at ICH6M
Plz put G12 close SW1 
						

							Chapter 5101
Clear Password
PIN Pad: Bypassing Password Check, Keep shorting G3(2 triangle pad) as above PIN pad and then powering 
on the system will force the BIOS to clear Supervisor and User passwords. That means both the power-on and 
setup passwords are all cleared. 
						

							Chapter 6102
This chapter gives you the FRU (Field Replaceable Unit) listing in global configurations of Aspire 9510 and 
TravelMate6500. Refer to this chapter whenever ordering for parts to repair or for RMA (Return Merchandise 
Authorization).
Please note that WHEN ORDERING FRU PARTS, you should check the most up-to-date information available 
on your regional web or channel. For whatever reasons a part number change is made, it will not be noted on 
the printed service guide. For ACER AUTHORIZED SERVICE PROVIDERS, your Acer office may have a 
DIFFERENT part number code from those given in the FRU list of this printed service guide. You MUST use 
the local FRU list provided by your regional Acer office to order FRU parts for repair and service of customer 
machines.
NOTE: To scrap or to return the defective parts, you should follow the local government ordinance or 
regulations on how to dispose it properly, or follow the rules set by your regional Acer office on how to 
return it.
NOTE: Please visit  website http://aicsl.acer.com.tw/spl/ for the up to date SPL.
FRU (Field Replaceable Unit) ListChapter 6 
						

							103Chapter 6
Exploded Diagram 
ItemDescriptionItemDescription
1 LCD bezel 2 LCD panel
3 LCD module 4 CAS camera upper case
5 Camera hinge 6 Camera cap
7 CCD PCB 8 Camera lower case
9 Left LCD bracket 10 Right LCD bracket
11 LCD cable 12 Middle cover
13 Upper case 14 Keyboard
15 Launch board 16 LED bracket
17 Touch pad 18 Touchpad bracket
19 Battery 20 Lower case
21 Mainboard 22 ODD
56
7
89:
21
22
23
2425
26
27
2829
2:313233
34
35
3637
38
TDBMF!! 1/411
2
3
4 
						

							Chapter 6104
23 ODD bezel 24 HDD
25 HDD cover 26 DIMM cover
27 Inverter board
ItemDescriptionItemDescription