Sharp R530es Service Manual

							R530EWT
11  –  6 4. SEALER FILM
1. Put the adhesive tape on the backing film of the sealer film as
shown in Fig. C-6.
2. Tear the backing film by pulling the adhesive tape.
3. Put the pasted side of the sealer film on the door panel.
                              Figure C-6. Sealer film
Sealer film
Backing film
Adhesive tape 
						

							R530EWT
12 – 1
R530EWTService Manual CHAPTER 12. CIRCUIT DIAGRAMS
[1] Pictorial Diagram
Figure S-1. Pictorial Diagram
HIGH
VOLTAGE
CAPACITOR
H.V. RECTIFIER
HIGH VOLTAGE COMPONENTS
OVEN LAMP
MAGNETRON
COM.
MONITOR
SWITCH
N.C.
SECONDARY
INTERLOCK
SWITCH
TURNTABLE
MOTOR
POWER
TRANSFORMER
COM.NO
BLU
RED
GRYGRY
ORG
WHT
ORG
WHT
BRNBLUREDBLUBLK
MAGNETRON TEMP FUSE CAVITY TEMP FUSE
FAN MOTOR
RED
BLK
GRY
ORG
ORGBLU
WHT
WHT
WHT
POWER SUPPLY
CORD 120V 60Hz
NOTE:
The neutral (WHT) wire must be connected to the
terminal with "N" mark on the power supply cord.BLKWHTGRY
H
N
NOTE:
The grounding conductor of
the power supply cord has
been grounded by power
supply cord fixing screw.
The screw must always be
kept tight.
COM.N.O.DOOR
SENSING
SWITCH
PNKGRN
GRN to Oven cavityGRN
PNK GRN2
1
CN-BWHT 1
CN-A
BRN
GRY
RED
WHT
BLK
GRYWHTWHT
WHT
SOURCE
LOAD LOADSOURCE
WHT
BLKAH SENSORREDWHT1
2
3CN-F
NOTE: Connect the GRY wire leads to the
cabinet side terminal of the power
transformer to avoid an operation
error of AH sensor.
CN-B
RY2
RY1PRIMARY
INTERLOCK
RELAY
CN-AT1
11
22CONTROL PANEL
(LSI UNIT)
(POWER UNIT)
CN-F
CN-C CN-G 
						

							R530EWT
12 – 2
[2] Power Unit Circuit
Figure S-2. Power Unit Circuit
+
Ð
+
Ð
+
Ð
A1
CN-A
R4 27
D5
T1
1
34
D1
D3
D2
D4 6
ab
cd
VRS1
(J1)
D7 D8
1SS270A 1SS270A10G471K
C1 0.1μ/50v
C3 0.1μ/50vZD1
HZ16-1
C5 10μ/35vC2 1000μ/35v
C4 10μ/35v R1 2.4k
1SS270A 1SS270A D1-D4
1N4002LD6
R5 4.7k
R2 680 1/2wR3 510 1/2w
R6 3.3k Q2 2SB1238
SP1 PKM22EPT Q1 2SB1238
RY1
RY2Q3 KRC243M
CN-C
12PIN LEAD
WIRE HARNESS
LED
GND
VC
VA
INT
VR
BUZZER
MICRO
NC
NC
DOOR
SENSING
SWITCH OVEN LAMP
TURNTABLE
MOTOR
FAN MOTOR AC
AC
MICRO
DOOR
SENSING
SWITCHOVEN LAMP
TURNTABLE
MOTOR
FAN MOTOR
C10
C2
C3
C1
C4
C9
C5
C6
C7
C8
C11
C12
A2
B2
B1 
						

							R530EWT
12 – 3
[3] LSI Unit Circuit
Figure S-3. LSI Unit Circuit 
C-10C-9C-1C-8C-12F-1F-2F-3
G1
G2
G3
G4
G5
G6
G7
G8
G9G10G11G12G13G14
C-11C-3C-4C-2
CN-C
GND
INT
VC
LED
VR
VA
OVEN LAMP
TURNTABLE
MOTOR
FAN MOTOR
BUZZERR
MICRO
NC
DOOR
SENSING
SWITCH
NC
AH SENSOR
NOTE: IF NOT SPECIFIED 1/10W
±5% CN-FD20
CN-G Q20
DTA143EAK
Q30
DTA143EAKR90
330 1w
IC-2
BA4558
CF1
CST4.00MGW
IC-1
72 37 36 1144109
108
73
R94
4.7k
R69 15k R97
15k
R41 15k R92 1.8kF R93 360kF R91
3.32kD
R96
3.57kD
R40
4.7k
R74 270k8
7
6
5 1
2
3
4
R95
15k
Q21
DTA123JKAD90 Q11
DTA143EAK
LD10LD11LD12LD13
LD15LD14C10 47 μ /16v
C11 0.1 μ /50v
C90 0.1 μ /50v
C91 0.1 μ /50v
C40 0.01 μ /25v
C60 330p/50v
C20
0.1 μ /50v
C13 0.01μ/25v
AIN0
AIN1
AIN2
AIN3C14 0.01μ/25v
C15
0.1μ/50vVL4
VL3
VL2
P44 P45
P20
P07 P06 P05 P04 P03 P02 P01 P00
P17
P16
P15
P14
AIN7
AIN6
AIN5 AIN4
P21 P22 P23 P24 CNTROVL1 C16
0.1μ/50v
C17
0.1μ/50v
C18
0.1μ/50vR12 15k
(J11) 4.7k (J10)
(J12)
(J14)
(J16) (J13) 4.7k
(J15) 4.7k
(J17) 4.7kR11 15kR10 1k
R15
4.7k R16
4.7k R17
0 R18
4.7k R98
620k
R99
300k
R100
150kF
R101
75kF
R102
37.4kF
R19
4.7k
C12
0.1 μ /50v
C920.01μ/25vC93
0.01μ/25v
ZD10
UDZ4.3B
Q10
2SA1037AK
Fresh
vegetablesBeverage
Center
Breakfast Lunch
Popcorn Snacks From the
Pantry
Start
Touch On
Fish
SeafoodPower
Level
Keep
Warm
Plus
15
Minute
Recipes
Defrost
CenterCustom
HelpBaked
potatoesSensor
reheatMinute
Plus
VegetablesRice1
62
73
84
95
0
Poultry Ground
meat
Entrees
Timer
Clock
Stop
Clear
C61 330p/50vC62 330p/50vC63 330p/50vC64 330p/50vC65 330p/50v
+
Ð
R75 270kR60 15k
R61 15k
R62 15k
R63 15k
R64 15k
R65 15k
R66 15k
R67 15k
R76 270kR77 270kR78 270kR79 270kR70 15kR71 15kR72 15kR73 15kR68 15k
C-6C-5C-7
COM14 COM15 COM5
COM6COM16
COM15
COM14
COM13
COM12
COM11
COM10
COM9
SEG40
SEG39
SEG38
SEG37
SEG36
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
COM1
COM2
COM3
COM4
COM5
COM6
COM7
COM8
COM0
COM5
COM15
COM8 SEG34
SEG39
P05
P04
P03
P02
P01
P00
P17
P16
P15
P14
AIN7
AIN6
AIN5
AIN4
RESET
NC
XCOUT
XCIN
NC
VCC
OSCSEL
XOUT
VSS
NC
XIN
NC
AIN3
AIN2
AIN1
AIN0
COM8
COM9
COM10
COM11
COM12
COM13COM7
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
SEG30
SEG31
SEG32
SEG33
COM4
COM3
COM2
COM1
COM0
VL1
VL2
VL3
VL4
VL5
C3
C2
C1
VLIN
VREG
NC
VSS
P27
P26
P25
P24
P23
P22
P21
P20
P47
P46
P45
P44
P43
CNTR0
P41
INT0
P07
P06SEG67 SEG66 SEG65
SEG64 SEG63 SEG62 SEG61 SEG60
SEG59 SEG58 SEG57 SEG56 SEG55 SEG54 SEG53
SEG52 SEG51 SEG50
SEG49 SEG48 SEG47
SEG46
SEG45 SEG44 SEG43
SEG42 SEG41 SEG40 SEG39 SEG38
SEG37 SEG36 SEG35 SEG34SENSORDEFROSTTURNTABLEOFFCOOK
HELP 
						

							R530EWT
12 – 4
[4] Printed Wiring Board of Power Unit
Figure S-4. Printed Wiring Board of Power Unit
WH-1
SH-B SH-A
1
C3
C4
C5 R3
C2
F
C1
10
D4
D2
D1
D3
(J1)
D9
(D10)
RY3 (CN-D) D8ZD1
VRB DUR2
R1
R6R5
SP1 3
EBD6 D5
Q2 R4
2
6
11PS
RY2T1
AC
VRS1 5D7
OMIF
DU 9 8 7
E
Q1B
4
E
RY1
ACOL
TTMFM
B
Q3 (CN-C)
CN-C
CN - B
CN - A
1
19
12
1
1
12
XA
VH
2
2 
						

							R530EWT
12 – 5 
						

							PARTS LIST
MICROWAVE OVEN
MODELS
This document has been published to be used
for after sales service only.
The contents are subject to change without notice.
R530EWT
R-530EK-T
R-
530EW-T
R-530ES-T
HOW TO ORDER REPLACEMENT PARTS
To have your order filled promptly and correctly, please
furnish the following information.
1. MODEL NUMBER
2. REF. NO.
3. PART NO.
4. DESCRIPTION
Parts marked * may cause undue microwave exposure.
Parts marked   are used in voltage than 250V. 
PartsGuide
[1] OVEN PARTS
[2] DOOR AND CONTROL PANEL 
PARTS for R-530EK-T/530EW-T[3] DOOR AND CONTROL PANEL 
PARTS for R-530ES-T
„INDEX
CONTENTS
DOOR PROTECTION SHEET
SPADPA204WRE0
TOP PAD ASSEMBLY
FPADBA685WRKZ
PLASTIC BAG
SSAKHA012WRE0
Not replaceable items.
PACKING CASE
SPAKCE564WREZ [R-530EK-T]
SPAKCE565WREZ [
R-530EW-T]
SPAKCE567WREZ [R-530ES-T]
BOTTOM PAD ASSEMBLY
FPADBA686WRKZ
6-3 TURNTABLE TRAY 6-6 OPERATION MANUAL
6-2 TURNTABLE SUPPORT
6-8 RECIPE CARD
INTO THE
OVEN CAVITY
FOAM SHEET
SPAKHA013WREZ
CABINET COVER for R-530EK-T & R530ES-T
SPAKHA026WREZ
TRAY PAD ASSEMBLY
CPADBA404WRKZ 
						

							R530EWT
 2
[1] OVEN PARTS
2-3
4-7
4-166-5
6-7
1-4
4-8
6-9 4-9
6-3
6-2
2-17-91-9 4-107-2 7-2
7-11 7-11
forR-530ES-T forR-530EK-T/EW-T
4-3
1-10 1-7
7-3
7-5 7-5
7-67-6
4-2
7-47-4
1-8
7-1 1-6
1-6
4-4
7-9
4-1
1-1
1-2
7-4
2-22-2
2-2 2-2 7-4
7-47-9
4-11 6-41-11 7-4
7-4
7-4 7-7
7-7
1-51-3
4-5 4-12
7-107-9
1-13
1-121-5
4-137-5
7-6 1-14
7-8
7-8
4-6
4-14
4-15 
						

							R530EWT
3
NO. PARTS CODEPRICE 
RANKNEW 
MARKPA R T  
RANKDESCRIPTION
[1] OVEN PARTS
ELECTRIC PARTS!1-1RC-QZA336WRZZ ASHigh voltage capacitor!1-1RC-QZA235WRE0 AUHigh voltage capacitor (Interchangeable)!1-1RC-QZB018MRE0 --High voltage capacitor for production use (Interchangeable)!1-2FH-DZA131WRKZ ANHigh voltage rectifier assembly
1-3RLMPTA087WRZZ ALOven lamp
1-3RLMPTA082WRZZ ALOven lamp (Interchangeable)
1-3RLMPTA085WRZZ ALOven lamp (Interchangeable)
1-4RMOTEA433WRZZ AXFan motor
1-4RMOTEA346WRE0 AVFan motor (Interchangeable)
1-5FFS-BA033WRKZ --Monitor fuse (20A) and monitor switch (V-5220Q)
1-5FFS-BA037WRKZ AN       (20A) and monitor switch (D3V-1G-2C25) (Interchangeable)
1-6QSW-MA085WRE0 AFSecondary interlock switch and door sensing switch
1-6QSW-MA147WRZZ AGSecondary interlock switch and door sensing switch
1-7QFS-TA014WRE0 AGCavity temperature fuse 150C
1-7RTHM-A145WRZZ AKCavity thermal cut-out 145C
!*1-8RV-MZA293WRE0 BHMagnetron!*1-8RV-MZA332WRZZ --Magnetron for production use (Interchangeable)
1-9RMOTDA264WRZZ ATTurntable motor
1-9RMOTDA186WRE0 AWTurntable motor (Inerchangeable)
1-9RMOTDA252WRZZ ANTurntable motor (Inerchangeable)
!1-10RTRN-A764WRZZ BHPower transformer
1-11FACCDA103WREZ AQPower supply cord
1-11FACCDA085WREZ AQPower supply cord (Interchangeable)
1-11FACCDA083WRE0 AQPower supply cord (Interchangeable)
1-12QFS-TA013WRE0 AGMagnetron temperature fuse 150C
1-12RTHM-A146WRZZ ALMagnetron thermal cut-out 145C (Interchangeable)
1-13FPWBFA437WRKZ ASNoise filter unit
1-14FDTCTA206WRKZ ATAH sensor
CABINET PARTS
2-1GDAI-A439WRWZ AZBase plate
2-2GLEGPA104WREZ AFLeg
2-3GCABUB116WRPZ BGOuter case cabinet (R-530EK-T)
2-3GCABUB118WRPZ BGOuter case cabinet (R-530EW-T)
2-3GCABUB120WRPZ BHOuter case cabinet (R-530ES-T)
OVEN PARTS
4-1LBNDKA163WRPZ AKH.V. Capacitor band
4-2LANGTA430WRPZ ALChassis support
*4-3PHOK-A130WRFZ AKLatch hook
4-4MLEVPA244WRFZ AGSwitch lever
4-5PDUC-B033WRFZ AMMagnetron duct
4-6NFANJA060WRFZ AHFan blade
4-7PDUC-A610WRF0 ARFan duct
*4-8------------- --Oven cavity (Not a replaceable part)
4-9PCOVPA465WREZ AGWaveguide cover
4-10PPACGA084WRF0 AETurntable motor packing
4-11PCUSGA630WRPZ ADCushion
4-12PCUSGA731WRPZ AFCushion
4-13PDUC-B031WRPZ AHSensor duct
4-14PCUSGA729WRPZ ABCushion
4-15PCUSGA730WRPZ AGCushion
4-16PCUSUA278WRP0 ABCushion
MISCELLANEOUS
6-2FROLPA117WRKZ BATurntable support
6-3NTNT-A099WRE0 AXTurntable tray
6-4TCAUAA292WRRZ AEMonitor caution label
6-5TCAUAA296WRRZ AHDHHS/Screw caution label (R-530EK-T/530EW-T)
6-5TCAUAA278WRRZ AGDHHS/Screw caution label (R-530ES-T)
6-7TCAUAA308WRRZ ADAC cord caution
6-9TLABMB191WRRZ ADMenu label
SCREWS, NUTS AND WASHERS
7-1XHPS740P08000 ABScrew : 4mm x 8mm
7-2LX-CZ0052WRE0 AASpecial screw
7-3XHTS740P12RV0 ACScrew : 4mm x 12mm
7-4XOTS740P12000 AAScrew : 4mm x 12mm
7-5XCBS730P06000 AAScrew : 3mm x 6mm
7-6XHTS740P08RV0 AGScrew : 4mm x 8mm
7-7LX-CZA070WRE0 ACSpecial screw (Torx tamper proof screw)
7-8XOTS840P08000 ABScrew : 4mm x 12mm (for R-530EK-T)
7-8XOTS740P12000 AAScrew : 4mm x 12mm (for R-530EW-T/ES-T)
7-9XHPS740P08K00 ABScrew : 4mm x 8mm
7-10XOTS740P10000 ABScrew : 4mm x 10mm
7-11XETS740P10000 AAScrew : 4mm x 10mm 
						

							R530EWT
4
[2] DOOR AND CONTROL PANEL PARTS for R-530EK-T/530EW-T
NO. PARTS CODEPRICE 
RANKNEW 
MARKPA R T  
RANKDESCRIPTION
[2] DOOR AND CONTROL PANEL PARTS for R-530EK-T/530EW-T
CONTROL PANEL PARTS
3-1DPWB-A558DRKZ BRControl unit
3-2FPNLCB959WRKZ BAPanel sub assy (R-530EK-T)
3-2FPNLCB960WRKZ BAPanel sub assy (R-530EW-T)
3-2-1FUNTKB297MRE0 ATKey unit (R-530EK-T)
3-2-1FUNTKB298MRE0 ATKey unit (R-530EW-T)
3-3JBTN-B442WRFZ AHOpen button (R-530EK-T)
3-3JBTN-B443WRFZ AHOpen button (R-530EW-T)
3-4HDECQA370WRFZ ALOpen button decoration (R-530EK-T)
3-4HDECQA371WRFZ ALOpen button decoration (R-530EW-T)
3-5MSPRCA157WREZ AFOpen button spring
3-6XEPS730P08XS0 ABScrew; 3mm x 8mm
DOOR PARTS
*5-1GWAKPB129WRRZ AXDoor frame (R-530EK-T)
*5-1GWAKPB131WRRZ AXDoor frame (R-530EW-T)
*5-2LSTPPA139WRF0 AELatch head
Actual wire harness may be different from illustration.
for R-530EK-T/530EW-T
6-1
5-5
5-6
3-2-1
3-3
3-5
3-4
5-4
5-9
5-2
3-2
3-6
3-6
3-1
5-7
5-1
6-6
6-8
5-3
5-8