Land Rover Range Rover 95 To 99my Maintenance Schedule Rover Manual

							SERVICE MAINTENANCE SCHEDULE Owners nameJob No.
New Range Rover -  95 to 99MYModel:
VIN/Engine No.
Available from RAVE CDSpeedometer:DateRegistration NoKilometres x 1000102030405060708090100110120130140150160Miles x 1000 or months6121824303642485460667278849096VEHICLE INTERIOR
1Check condition and security of seatbelts, seat belt mountings, seat belt buckles and operation of inertia seat belts.········2Check operation of lamps and all warning indicators.················3Check operation of front/rear wipers and washers and condition of wiper blades.················4Check operation of handbrake and adjust if required.········5Depressurise electronic air suspension and renew intake filter.····6Renew electronic air suspension compressor intake filter.····7Remove/refit air reservoir drain plug (if evidence of water in system, replace dryer).····8Repressurise air suspension system.····VEHICLE EXTERIOR 
9Check/adjust headlamp and auxiliary lamp alignment.····10Remove road wheels.········Check tyres for compliance with manufacturers specification, visually for cuts, bulges, uneven wear and depth, 
tyre pressures (including spare) adjust if required.
12Inspect brake pads for wear, calipers for leaks and discs for condition.········13Refit road wheels to original hub position.········14Check front wheel alignment.········15Lubricate door locks, check straps, bonnet catches and fuel flaps.········UNDER BONNET
16Check cooling, intercooler and heating systems for leaks, hoses for security and condition. Top up as required.················17Renew spark plugs.····18Renew fuel filter element diesel.·····19Drain water from fuel filter (diesel).···········20Renew air cleaner element and clean drain holes (diesel).········21Renew air cleaner element and clean drain holes (V8).····22Renew pollen filters.········23Renew charcoal canister.·24Check condition of driving belts (Poly V).····25Renew ancillary driving belts  (Poly V).·26Check/top up automatic transmission fluid.·····27Check/top up power steering fluid reservoir.·········28Check/top up brake and clutch fluid reservoirs.·········29Check/top up windscreen and rear screen washer reservoir.················30Lubricate accelerator and cruise control linkage.········31Remove battery connections - clean, grease and refit.····32Visually check intercooler/radiator for external obstructions.········33Flush diesel intercooler.··34Check condition of steering intermediate shaft.····11········ 
						

							Kilometres x 1000102030405060708090100110120130140150160Miles x 1000 or months6121824303642485460667278849096UNDER VEHICLE
35Renew engine oil and filter (diesel).················36Renew engine oil and filter ( V8) .·········37Renew gearbox oil.····38Check/top up gearbox oil.····39Renew automatic transmission oil and filter.····40Renew transfer box oil.····41Check/top up transfer box oil.····42Renew front and rear axle oil.····43Check/top up front and rear axle oil.····44Lubricate propeller shaft universal/sliding joints.········45Renew fuel filter (V8).·Visually check brake servo hose, brake, fuel, clutch pipes/unions for chafing, leaks and corrosion.
Investigate if necessary.
47Check exhaust system for leaks, security and damage.········48Renew oxygen sensors (V8i only).·49Renew catalytic converters (V8).·50Check for chafing, corrosion and fluid leaks from steering and suspension systems hydraulic pipes and unions.········51Check/tighten steering unit and steering rod ball joint fixings, check condition of ball joints and dust covers.········52Check air suspension pipes and springs for security and damage.········53Check shock absorbers/height sensors and harness assembly for leakage and damage.········54Check air susoension pipes and springs for security and damage.········55Check security of towing bracket.········56Check road wheel speed sensor electrical harness for damage.········57Carry out road test, check for correct function of all systems.················58Carry out road roller test (see notes).················59Endorse service record and report any unusual features of vehicle condition and additional work required.················CAMSHAFT DRIVE BELT: The 4 cylinder engine timing gears are driven by a flexible rubber belt which must be renewed at intervals determined by theAt 80,000 km (48,000 miles) intervals or every four years whichever is the earlier, all hydraulic brake fluid seals, brake servo filter and
severity of the operating conditions. In reasonable, temperate climate operation, renew the belt every 120,000 km (72,000 miles) or every 6 years flexible hoses should be renewed. All working surfaces of the master cylinder and caliper cylinders should be examined and renewed
whichever occurs earlier (Tdi) or 160,000 km (96,000 miles) (MPi). In conditions such as work in dusty atmospheres, high ambient temperatures and   where necessary.
 desert and tropical zones, renew belt every 60,000 km (36,000 miles) or every three years (Tdi) 80,000 km (48,000 miles) or every 4 years (MPi).ABS vehicles only - renew hydraulic brake fluid and flexible hoses, examine the working surfaces of the caliper cylinders and renew the 
whichever occurs earlier.seals or cylinders where necessary. ABS vehicles used extensively in arduous/off road conditions - check the rear road speed sensor 
OIL CHANGE 300 Tdi ENGINES: If the vehicle is operated on fuel with high sulphur content (over 1%) the oil change interval must not exceed for abrasive wear at 1,00 km (1,000 miles) intervals
5,000 km (3,000 miles)Air suspension vehicles used extensively in arduous/off road conditions will require the compressor inlet filter to be replaced at more
ANTIFREEZE - ALL MODELS: At two yearly intervals or at the onset of the second winter, the cooling system must be drained, flushed and refilled regular intervals.
with the required water and antifreeze solution.When the vehicle is used in dusty or field conditions, frequent attention to the air cleaner is required.
VEHICLES FITTED WITH AIR BAGS: The air bags must be replaced every TEN YEARSWARNING: Two wheel roller test must not be carried out. Four wheel roller test must be restricted to 5 km/hour (3Miles/hour)
IT IS RECOMMENDED THAT:
At 20,000 km (12,000 miles) intervals clean the sunroof drain tubes and channels and lubricate guide rail slidesOperators signature
At 40,000 km (24,000 miles) intervals or every two years whichever is the earlier, the hydraulic brake fluid should be completely renewed
Note: A copy of this schedule should be retained in the customer/vehicle history file····46····