Land Rover Landrovercatno4 Goldcoastrovers Manual

							DRIVE COMPONENTS RANGE ROVER CLASSIC
*Denotes Aftermarket PartGOLD COAST ROVERS () 
RANGEROVERCLASSIC
Description Order Number Explanatory Notes Qty
1. Front Driveshaft Assembly RVFRC8641 3.5 Liter Only 1
1. Front Driveshaft Assembly RVFRC9542 3.9 and 4.2 1
2. Rear Driveshaft Assembly RVFRC8387 SWB (100) through 1994 1
2. Rear Driveshaft Assembly RVTVB000150 SWB (100), 1995 only 1
2. Rear Driveshaft Assembly RVFRC8389 LWB, through 1994 1
2. Rear Driveshaft Assembly RVFTC3910 LWB, 1995 only 1
3. UJoint Assembly JA46 Front Driveshaft, all. Rear Driveshaft, all SWB
and 1995only LWB 4
3. UJoint, Rear Driveshaft RVRTC3458* LWB through 1994 2
4. Rubber Coupler, Rear Driveshaft RVTVF100010 1995 only, Original Equipment 1
4. Rubber Coupler, Rear Driveshaft RVTVF100010/X 1995 only, Aftermarket 1
5. Gaiter/Boot, front drive shaft RV276483 1

Rear DriveshaftFront Driveshaft




 
						

							DIFFERENTIAL AND COMPONENTS RANGE ROVER CLASSIC
GOLD COAST ROVERS () *Denotes Aftermarket Part
RANGEROVERCLASSIC
DescriptionOrder Number Explanatory Notes Qty/Diff.
For TenSpline Axles; used in front to axle numbers 49L11363C/57L05188 and rear up to VIN PA637567 (during 1993 MY)
1.Differential Assembly, Front or Rear, New RVFTC2750 A/R
1. Differential Assembly, Front or Rear, Rebuilt RVFTC2750/RB A/R
For 24Spline Axles; from axle numbers 49L11364C/57L05189B
1. Differential Assembly, Front, New RVFTC5142 A/R
1. Differential Assembly, Front, Rebuilt RVFTC5142/RB A/R
For 24Spline Axles; From PA63337568 to RA647644
1.Differential Assembly, Rear, New RVFTC5142 A/R
1.Differential Assembly, Rear, Rebuilt RVFTC5142/RB A/R
For 24Spline Axles; 1995
1. Differential Assembly, Rear, New RVFTC5143 A/R
1.Differential Assembly, Rear, Rebuilt RVFTC5143/RB A/R
2. Differential Side Bearing RVRTC2726 To 49L11363C and 57L05188B 2
2. Differential Side Bearing RVRTC3095 From 49L11364C and 57L05189B 2
3. Washer on Drain Plug RV515599 1
4. Drain Plug RV608246 1
5.Gasket, Housing to Axle RV7316 1
6.Pinion Bearing, rearRV539706 1
7. Pinion Bearing, front RV539707 1
8. Oil Seal, Pinion RVFRC8220 1

Note: Front and rear differentials are identical;
the parts listed below will fit either end.
QUANTITIES ARE PER DIFFERENTIAL,
NOT PER VEHICLE.








 
						

							FRONT AXLE RANGE ROVER CLASSIC
*Denotes Aftermarket PartGOLD COAST ROVERS () 
RANGEROVERCLASSIC
Description Order Number Explanatory Notes
1. ConstantVelocity Joint RV606665 Non ABS, suffix A Axle
1. ConstantVelocity Joint RVRTC5843 Non ABS, suffix Bon
1. ConstantVelocity Joint RVRTC6811 With ABS, up to 49L11363C/57L05188B
1.ConstantVelocity Joint RVTDJ000010 With ABS, from 49L11363C/57L05189B
2. Front Halfshaft, Separate, RH RV606662 Non ABS, Suffix A Axle (Larger O/D)
2. Front Halfshaft, Separate, LH RV606663 Non ABS, Suffix A Axle
2. Front Halfshaft, Separate, RH RVRTC5840 Non ABS, Suffix B Axle (Smaller O/D)
2. Front Halfshaft, Separate, LH RVRTC5842 Non ABS, Suffix B Axle
2. Front Halfshaft, Separate, RH RVRTC6754 With ABS up to 49L11363C/57L05188B
2. Front Halfshaft, Separate, LH RVRTC6755 With ABS up to 49L11363C/57L05188B
2. Front Halfshaft, Separate, RH RVSTC3049 With ABS from 49L11363C/57L05189B
2. Front Halfshaft, Separate, LH RVSTC3050 With ABS from 49L11363C/57L05189B
3. Front Halfshaft Assembly RV571895 Through 1992, RH, no ABS, Suffix A
3. Front Halfshaft Assembly RV571896 Through 1992, LH, no ABS, Suffix A
3. Front Halfshaft Assembly RVFRC9518 Through 1992, RH, no ABS, Suffix Bon
3. Front Halfshaft Assembly RVFRC9519 Through 1992, LH, no ABS, Suffix Bon
3. Front Halfshaft Assembly RVFTC862 RH, 19931995, to 49L11363C & 57L05188B
3. Front Halfshaft Assembly RVFTC863 LH, 19931995, to 49L11363C & 57L05188B
3. Front Halfshaft Assembly RVFTC3146 RH, 19931995, from 49L11364C & 57L05189B
3. Front Halfshaft Assembly RVFTC3147 LH, 19931995, from 49L11364C & 57L05189B



 
						

							SWIVEL PINS RANGE ROVER CLASSIC
GOLD COAST ROVERS () *Denotes Aftermarket Part
RANGEROVERCLASSIC
DescriptionOrder Number Explanatory Notes
1.Spacer RVRTC5841
2. Swivel Pin Bushing, two per side RVFTC125 With ABS
3. Bearing Housing (Swivel Ball) RVFTC5105 With ABS
3. Bearing Housing (Swivel Ball) RVFRC7065 Without ABS
4.Oil Seal, at swivel housing RV571718
5. Gasket, Bearing Housing RVFTC3646
6. Seal, Swivel Pin Housing, Outer RV571890 12.5mm thick, without ABS
6. Seal, Swivel Pin Housing, Outer RVFTC3401 9mm thick, some nonABS, all with ABS
Note: For non ABS applications, either seal could have been fitted. Rover is not specific.
7. Washer RV571755 Without ABS
8. Shim, .450mm RVFRC6782 With ABS, use as required
8. Shim, .600mm RVFRC6783 With ABS, use as required
8. Shim, .750mm RVFRC6784 With ABS, use as required
8.Shim, .900mm RVFRC6785 With ABS, use as required
8.
Shim, 1.050mm RVFRC6786 With ABS, use as required
8.Shim, 1.200mm RVFRC6787 With ABS, use as required
8. Shim, 1.350mm RVFRC6788 With ABS, use as required
8. Shim, 1.500mm RVFRC6789 With ABS, use as required
8. Shim, 1.650mm RVFRC6790 With ABS, use as required
9. Circlip, RR with ABS RV549473 With ABS
10. Hub Cap RVFTC5414 With ABS

Outboard
Inboard







Originally Land Rover filled the swivel pins with weight oil
which was prone to leaking This special grease replaces the gear oil
and is packaged in singleuse containers Use one tube per swivel on
every service job
Swivel Pin Grease RVSTC3435 
						

							SWIVEL PINS RANGE ROVER CLASSIC
*Denotes Aftermarket PartGOLD COAST ROVERS () 
RANGEROVERCLASSIC
Description Order Number Explanatory Notes
1. Seal, Upper Swivel Pin RVFTC1376 With ABS
2. Upper Swivel Pin RV571756 Without ABS
3.Shim, Upper Swivel Pin, .003 RV571743 Without ABS
3.Shim, Upper Swivel Pin, .005 RV571744 Without ABS
3. Shim, Upper Swivel Pin, .010 RV571745 Without ABS
3. Shim, Upper Swivel Pin, .030 RV571746 Without ABS
3. Shim, Upper Swivel Pin, .003 RVFRC2883 With ABS
3. Shim, Upper Swivel Pin, .005 RVFRC2884 With ABS
3. Shim, Upper Swivel Pin, .010 RVFRC2885 With ABS
3. Shim, Upper Swivel Pin, .030 RVFRC2886 With ABS
4.Upper Swivel Pin Kit RVSTC226 With ABS
5. Bearing Only, Upper or Lower Swivel Pin RV606666 Without ABS
6. Gasket, Lower Swivel Pin RV571815 Without ABS
6. Gasket, Lower Swivel Pin RVFTC3647 With ABS
7. Lower Swivel Pin RV571819 Without ABS
7.Lower Swivel Pin RVFRC2894* With ABS
8.Drain Plug RV236070
9. Gasket RVFTC3648
10. Stub Axle RVFRC8005 Non ABS, Suffix A Axles, requires 571821 bushing
10. Stub Axle RVFTC57 Non ABS, Suffix B Axles
10. Stub Axle RV6700 With ABS, through 1992
10. Stub Axle RVFTC3154 With ABS, 1993on
11. Oil Seal, stub axle, in swivel pin housing RVFTC840 With ABS to 57L05188B
11. Oil Seal, stub axle, in swivel pin housing RVFTC5268 With ABS from 57L05189B
12. Bearing, Stub Axle, in swivel pin housing RVFTC861 With ABS
13.Stub Axle Bushing RV571821 Non ABS, Suffix A Axles Only
14. Fill Plug RVFTC3670
15Bushing, ABS Sensor RVFTC1374 On upper swivel pin Housing

Outboard
Inboard











 
						

							FRONT HUBS RANGE ROVER CLASSIC
GOLD COAST ROVERS () *Denotes Aftermarket Part
RANGEROVERCLASSIC
DescriptionOrder Number Explanatory Notes
1.Hub Gasket RV571752
2.Lock Nut RVFRC8700
3. Key Washer RVFRC8002 Without ABS
4. Key Washer RV217352 With ABS to end of 1992
4. Key Washer RVFTC5241 With ABS, 19931995
5. Hub Seal RVFRC8222 Without ABS (ABS applications do not use an outer seal.)
6. Bearing RVRTC3429 Two per wheel
7. Inner Hub Seal RVFTC4785
8. Washer RV217353 With ABS, through 1992
8. Washer RVFTC3179 19931995; Always replace when changing brake rotors
9. Hub Assembly, with Studs RVFTC1457 Without ABS
9. Hub Assembly, with Studs RVFTC942 With ABS

Wheel Bearing Kit:
Includes two bearings and seals, each kit will service one front wheel
Description Order Number Explanatory Notes
Wheel Bearing Kit RV5000 19871992 Without ABS
Wheel Bearing Kit RV5001 19871992 With ABS
Wheel Bearing Kit RV5002 19931995
NONABS
EQUIPPED
ILLUSTRATED
PARTSABS EQUIPPED
I
LLUSTRATED
P
ARTS












Outboard
Inboard
 
						

							REAR AXLE AND HUBS RANGE ROVER CLASSIC
*Denotes Aftermarket PartGOLD COAST ROVERS () 
RANGEROVERCLASSIC

Description Order Number Explanatory Notes
1. Seal RVFTC5268
2. Joint Washer RVFTC3648 Without ABS
3. Hub Seal, inner RVFTC4785
4. Wheel Bearing RVRTC3429 Also see bearing kits, 2/ Wheel
5. Hub Seal, outer RVFRC8222 Without ABS
6.Lock Nut RVFRC8700
7. Key Washer RVFRC8002 Without ABS
8. Joint Washer RV571752
9. Axle Shaft, RH RV571882 Without ABS
9. Axle Shaft, LH RV571883 Without ABS
10. Joint Washer RVFTC3650 With ABS
11.Shim, .450mmRVFRC6782 With ABS through 1992; use as required
11. Shim, .600mm RVFRC6783 With ABS through 1992; use as required
11.Shim, .750mm RVFRC6784 With ABS through 1992; use as required
11. Shim, .900mm RVFRC6785 With ABS through 1992; use as required
11. Shim, 1.050mm RVFRC6786 With ABS through 1992; use as required
11. Shim, 1.200mm RVFRC6787 With ABS through 1992; use as required
11. Shim, 1.350mm RVFRC6788 With ABS through 1992; use as required
11. Shim, 1.500mm RVFRC6789 With ABS through 1992; use as required
11. Shim, 1.650mm RVFRC6790 With ABS through 1992; use as required
12. Hub Assembly, with Studs RVFTC942 With ABS Only
13. Key Washer RV217352 With ABS up to 35S16958B (coil suspension) and
37S00315A (air suspension)
13. Key Washer RVFTC5241 With ABS from 35S16959B (coil suspension) and
37S00316A (air suspension).
13. Key Washer RVFTC3179 With ABS from 35S16959B (coil suspension) and
37S00316A (air suspension).
14. Key Washer RV217353 With ABS up to 35S16958B (coil suspension) and
37S00315A (air suspension).
15.Circlip RV549473 With ABS through 1992
16. Hub Cap RVFTC5414 With ABS through 1992
17.Axle Shaft, RH RVFTC870 With ABS Through 1992
17.Axle Shaft, LH RVFTC871 With ABS Through 1992
17. Axle Shaft, RH RVFTC3186 1993On, Up to axle numbers 35S18188C & 37S08650B
17. Axle Shaft, LH RVFTC3187 1993On, Up to axle numbers 35S18188C & 37S08650B
17. Axle Shaft, RH RVFTC3270 1993On, From axle numbers 35S18189C & 37S08651B
17. Axle Shaft, LH RVFTC3271 1993On, From axle numbers 35S18189C & 37S08651B
18. Wheel Bearing Kit RV5003 Without ABS
18.Wheel Bearing KitRV5004 With ABS 19871992 & 19931995
without air suspension
18. Wheel Bearing Kit RV5005 19931995 with air suspension




















N
ONABS EQUIPPEDABS EQUIPPED




 
						

							WHEELS RANGE ROVER CLASSIC
GOLD COAST ROVERS () *Denotes Aftermarket Part
RANGEROVERCLASSIC
Description Order Number Explanatory Notes
1. Lug Nut RVNRC7415 Plain steel, to PA635839
1.Lug Nut RVANR2763MMM Stainlesscapped, from PA635840
2. Wheel Center Cap RVNRC8254 Threespoke wheels; “Range Rover” Logo
2. Wheel Center Cap RVRTC7641 Threespoke wheels; “County” Logo
2. Wheel Center Cap RVANR2391MNH To 1995 with fivespoke wheels; “Silver Sparkle”
2. Wheel Center Cap RVANR2391MUE To 1995 with fivespoke wheels; “Quicksilver”
3. Alloy Wheel RVSTC8126 FiveSpoke
4.
Alloy Wheel RVANR1406MUE ThreeSpoke
Description Order Number Explanatory Notes
1.Handbrake warning switch RVADU2888L All
2.Brake Light Switch RV13H3735L* Without ABS
2. Brake Light Switch RVAMR2010 With ABS
3. Brake Pedal Pad RVCRC570 Up to PA638528 (1993)
3. Brake Pedal Pad RVANR2941 BPA638520on (1993)

BRAKES ELECTRICAL AND PEDAL RANGE ROVER CLASSIC






 
						

							BRAKES MASTER CYLINDER AND COMPONENTS RANGE ROVER CLASSIC
*Denotes Aftermarket PartGOLD COAST ROVERS () 
RANGEROVERCLASSIC
Description Order Number Explanatory Notes Qty
1. Nonreturn valve on servo RVRTC5636 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
1. Nonreturn valve on servo RVSTC780 Girling Master Cylinder 1
2. Brake Servo, Lockheed RVAEU1715 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
2. Brake Servo, Girling  RVSTC1286 Girling Master Cylinder 1
3. Nonreturn valve on manifold RVLKX100440 Lockheed or Girling Master Cylinder 1
4. Pressure Switch RVPRC2583 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
5.Master Cylinder RVRTC3658 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.)1
6. Master Cylinder RVNTC4991 Girling Master Cylinder;
Reservoir has an angled top;
has wire to filler cap; up to JA624755. 1
7. Master Cylinder Cap RV513123 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
8.Filler Cap/Switch on Reservoir RVRTC5831 Girling Master Cylinder 1
9. Front Brake Hose, per each RVNRC4401* Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 2
9. Front Brake Hose RVNRC4401* Girling Master Cylinder, to VIN MA610293 2
9. Front Brake Hose RVNTC7670 Girling Master Cylinder, from VIN MA610294 2
10. Rear Brake Hose RVNTC3458 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
10. Rear Brake Hose RVNTC3458 Girling Master Cylinder 1
11.Rebuild Kit, Lockheed Servo RVAEU1021 Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
11. Repair Kit, Girling Servo RVRTC5832 Girling Master Cylinder 1
12. Brake Reservoir Overhaul Kit RVRTC5833 Girling Master Cylinder 1
13.Overhaul Kit, Master Cylinder RVAEU1894* Lockheed Master Cylinder, non ABS
(1987 & 1988, reservoir top is flat.) 1
13.Overhaul Kit, Master Cylinder RVRTC5834 Girling Master Cylinder 1













 
						

							BRAKES ABS SYSTEM  RANGE ROVER CLASSIC
GOLD COAST ROVERS () *Denotes Aftermarket Part
RANGEROVERCLASSIC
Description Order Number Explanatory Notes Qty
1. Brake Booster  RVSTC886 1
2. Cap, Brake Reservoir  RVNTC9858 1
2.Seal, Brake Reservoir Cap RVRTC6490 1
2. Filter, Brake Reservoir RVRTC6493 1
3. Brake Fluid Reservoir RVRTC6741 1
4. Pump, pressure, to PA632922 RVSTC885 1
4. Pump, pressure, from PA632923 RVSTC1181 1
5. Brake Accumulator RVRTC6498 1
6. High Pressure Hose to Accumulator RVNTC5920 Through 1994 1
6. High Pressure Hose to Accumulator RVANR3489 1995 1
7. Bushing, ABS Sensor RVFTC1374 On Rear Axle 2
8. Sensor & Harness Assembly, ABS RVSTC90 Front RH or LH, through 1991 4
8. Sensor & Harness Assembly, ABS RVSTC1864 Front, Right Side19921995 4
8.Sensor & Harness Assembly, ABS RVSTC1865 Front, Left Side 19921995 4
8. Sensor & Harness Assembly, ABS RVSTC1866 Rear, all 4
9. Rear Brake Hose RVNTC3458 2
10. Front Brake Hose RVNRC4401* to VIN MA610293  (mid 1991); (two per side) 4
10. Front Brake Hose RVNTC7670 VIN MA610294on (mid 1991): two per side) 4
11. Copper Washer on Banjo Fittings RVSTC1554 2
12.Brake Pressure Reducing Valve RVNTC6868L With or without ABS, except 1993on “County” 1
12.Brake Pressure Reducing Valve RVNTC9753 1993on “County” models 1