Brinkmann Brinkman Q Beam Max Million Spotlight And Magnum Max 850,000 Cp Spotlight Owners Manual

							OWNER’S MANUAL &
OPERATING INSTRUCTIONS
®
MAX MILLION™Spotlight &
Magnum Max
® 850,000 CP Spotlight
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE. 
						

							1
• Never place spotlight lens (face) down when light is on or is still hot from recent use. Doing so could burn/ignite surfaces
such as seats, carpeting, etc. and cause major property damage. Always turn spotlight off and unplug from power source
when not in use.
• To prevent serious damage to eyesight, never look into spotlight when light is on. Do not shine light into the face of
someone else.
• Do not touch lens of spotlight when light is on or if it was recently on. The lens will be hot and could cause serious burns.
• Keep battery clips or cigarette lighter plug dry and out of water at all times.
• Do not place spotlight in water. 
• Do not allow children to handle or operate this spotlight.
• Do not use this product for other than its intended use.
• Do not operate in close proximity of combustible or flammable materials.
• Do not attempt to operate spotlight if cord, plug, bulb or any part of the spotlight is damaged or corroded.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR SPOTLIGHT.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
IMPORTANT SAFETY WARNINGS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL 
BEFORE OPERATING SPOTLIGHT.
WARNING
• Never attempt to wipe or clean the inner reflective surface of the
reflector. Touching or wiping the surface will damage it permanently.
• The lens is made of optical-quality, tempered glass. As with all glass,
avoid dropping or sharp impact on spotlight. 
• Do not allow the hot lens to come in contact with water or materials
subject to heat damage.
• This spotlight is weather resistant. It is not waterproof. Do not use
the spotlight under water or store outdoors. 
• Only use a Brinkmann 12-volt, halogen bulb that is designed for your
Q-Beam spotlight. Use of any other bulb may result in poor
performance and may damage your spotlight.
• After months of use, cigarette lighters can build up corrosion that
may prevent your Q-Beam spotlight from making good contact. It
may be necessary to clean the inside of your cigarette lighter
receptacle with a fine emery cloth. Before cleaning receptacle, remove
the fuse to prevent it from shorting out.Tips to Avoid Damage to
Your Q-Beam Spotlight 
						

							OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL 
BEFORE OPERATING SPOTLIGHT.
Step 1:To activate spotlight, plug the cigarette lighter adapter into a
cigarette lighter receptacle. Move switch to ON. 
WARNING:Never place spotlight lens face down when light is on or
is still hot from recent use. Doing so could burn/ignite
surfaces such as seats, carpeting, etc. and cause major
property damage. Always turn spotlight off and unplug
from power source when not in use.
Step 2:To deactivate, move switch to OFF and unplug from power
source.
M
A
D
E
 
I
N
 
U
.
S
.
A
.
To Replace Bulb
Lens Rear
Housing
Front
HousingReflector
Only use a Brinkmann halogen bulb that is designed for the Q-Beam Max
Million or Magnum Max 850,000 CP spotlight as a replacement. Use of
any other bulb may result in poor performance and may damage your
spotlight.
IMPORTANT:Do not touch the glass part of bulb with fingers as natural
oils affect the life and performance of bulb. Handle bulb by
metal end only.
Step 1:Disconnect spotlight from power source.
Step 2:Remove the two screws from top and bottom of front housing
(see Figure 1).
Step 3:Lay the spotlight face (lens) down on a flat surface.
Step 4:Holding the front housing secure, slowly lift the rear housing off
being careful not to pull wire connections inside. Make sure the
reflector is inside the front housing as shown in Figure 2. Do
not touch the inside of reflector.
NOTE:The glass lens is not attached to front housing. Use care when
disassembling to avoid breaking lens.
2
FIGURE 1 
						

							Step 5:Disconnect bulb wire from connector by holding the connector
firmly with fingers then pulling bulb wire straight out as shown
in Figure 2.
Step 6:Spread the wire retainer apart and lift up as illustrated in 
Figure 3.
Step 7:Pull bulb straight out from the reflector mounting plate.
Step 8:To install new bulb, grasp the bulb from the metal end (DO NOT
TOUCH THE GLASS PART) and insert into the reflector 
mounting plate. Align the slots in the bulb base with those in
the reflector mounting plate.
Step 9:Replace wire retainer by spreading ends apart while pressing
down. Push ends together so they catch on the reflector 
mounting plate.
Step 10:Reconnect the bulb wire to the connector as illustrated in 
Figure 4.
Step 11:To reassemble spotlight, leave the front housing face (lens)
down on a flat surface with the reflector in the front housing.
Insert the rear housing into the front housing of the spotlight.
Step 12:Replace the two screws that were removed in Step 2. Do not 
over tighten screws.
Replacement bulbs and accessories may be purchased from 
The Brinkmann Corporation Consumer Sales Department by 
calling 1-800-468-5252.
3
Connector
Connector
FIGURE 3
FIGURE 4FIGURE 2 
						

							4
Q-BEAM ACCESSORIES
Pigtail AdaptersPigtail adapter with battery terminal clips
allow Q-Beam spotlights with cigarette lighter
plug to operate directly from a 12-volt battery.
Model 802-1704-0 (2-Ft. Cord) 
Model 802-1705-0 (10-Ft. Cord) 
Rechargeable Battery Pack
With Carrying Case
12-volt rechargeable battery pack adds total
mobility to your Q-Beam. Includes cigarette
lighter receptacle, 120-volt charging 
transformer and a heavy-duty, woven nylon
carrying case with shoulder strap.
Model 802-1724-1 Black
Model 802-1725-1 Green Camo
Lighter Plug Extension CordFeatures a 15-ft. cord with a cigarette lighter
plug and receptacle.
Model 802-1706-0
LOOK FOR THESE ACCESSORIES AT YOUR LOCAL RETAILER
WHERE Q-BEAMS ARE SOLD, OR ORDER DIRECT 
BY CALLING 1-800-468-5252. 
						

							Snap-On Lens Filter Filter lens snap-on easily to Q-Beam spotlight for
color and visual effect.
Model 802-1703-1  Amber
Model 802-1703-2  Red
Model 802-1703-3  Blue
Model 802-1703-4  Assortment Pack 
(1 Amber, 1 Red, 1 Blue)
5
Replacement Bulb12-volt, halogen bulb is an original 
replacement for Q-Beam Max Million 
or Magnum Max 850,000 CP spotlights.
Model 802-1740-0  Max Million Spotlight
Model 802-1742-0  Magnum Max Spotlight
Wall Mount Bracket Mounts to any flat surface for storage of Q-Beam
spotlights. Screws included.
Model 802-1708-0
Carrying CaseBlack, vinyl carrying case is ideal for storage
and transport of your Q-Beam hand-held 
spotlight.
Model 802-1702-0
Q-BEAM ACCESSORIES
LOOK FOR THESE ACCESSORIES AT YOUR LOCAL RETAILER
WHERE Q-BEAMS ARE SOLD, OR ORDER DIRECT 
BY CALLING 1-800-468-5252. 
						

							For 1-year from date of purchase, The Brinkmann Corporation warrants the Q-Beam Max Million/Magnum Max Spotlight against
defects due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty
are limited to the following guidelines:
• This warranty does not extend to the bulb.
• This warranty does not cover spot lights that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
• This warranty does not cover surface scratches or weathering as this is considered normal wear.
• Warranty service is limited to repair or replacement of spotlights which prove defective under normal use and which upon
examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms the defect and approves the
claim, Brinkmann will elect to repair or replace the spotlight as covered by the terms of this warranty.
• This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain repair or replacement of your Q-Beam Max Million/Magnum Max Spotlight under the terms of this
warranty, please call Customer Service Department at 1-800-527-0717 for a Return Authorization Number and further
instructions. A receipt will be required. A Return Authorization Number must be clearly marked on the outside of the box.
Spotlights returned to Brinkmann must include your name, address and telephone number. Please make sure the light is
properly packed, postage prepaid, and insured. Brinkmann cannot be responsible for any spotlights forwarded to us without a
Return Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION
TO 1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED
WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE Q-BEAM
MAX MILLION/MAGNUM MAX SPOTLIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED.
CUSTOMER ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE
WARRANTY SET OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES
YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
1-YEAR LIMITED WARRANTY
140-2485-0
8/96, 12/01