Bissell 6594w Manual

							Use only BISSELL Replacement Bulbs in your BISSELL 
PowerForce Bagless.
Unplug cleaner from electrical outlet
Using a flat screwdriver, table knife or coin, insert into the 
slot on the right of the lens and gently push inner latch 
to the left as shown to remove the lens.
Standard Bulb – remove the bulb from the socket by 
grasping bulb and pulling straight out. Install the new bulb 
by pushing it gently into the socket until the bulb snaps 
into place. 
Large Bulb - remove the bulb from the socket by pushing 
bulb in gently and turning it towards brush. Install the new 
bulb by pushing it gently into the socket and turning away 
from the brush.
Reposition lens, by inserting tab on left side and then 
pushing the right side back into place.
Low suction, poor pickup, or no suction may be 
due to a clog in the vacuum cleaner. If you notice a 
change in the sound of the motor or a reduction in the 
spinning action in the Dirt Container, check for clogs.
Unplug cleaner from electrical outlet.
Empty Dirt Container.
Check Upper Tank and Louvers for build up or clogs.  
Check to make sure Louvers are installed correctly. To 
unlock the Louvers, grasp the rim and turn toward the left. 
Pull straight down to remove. If the Louvers are missing 
or not locked into place, check and clear the tube in the 
center of the Dirt Container.
Remove the Twist ‘n Snap Hose from the vacuum by 
turning to the left. Check the Suction Inlet, Hose and Hose 
Wand for clogs. Remove any clogs from the hose using a 
long, narrow object.
Check the Foot Hose for clogs. If needed, remove the screw 
attaching the Hose Wand Base to the vacuum. Straighten 
the Foot Hose and unclog with a long, narrow object.
If the clog persists, follow the instructions for Checking 
the Rotating Floor Brush on page 10 and inspect the Air 
Passageway for obstructions.
1.
Replace Lightbulb
11
2.
3.
4.
1.
2.
3.
4.
5.
6.
Clearing Clogs
Suction 
Inlet
Air Passageway
Louvers
Hose 
Wand BaseLarge Bulb
Standard Bulb 
						

							12
Troubleshooting
Vacuum cleaner won’t run
Possible Causes Remedies
  Power cord not plugged in    Check electrical plug
  Blown fuse/tripped breaker    Check/Replace fuse or 
    reset breaker
Vacuum cleaner won’t pick up dirt
Possible Causes Remedies
  Incorrect Height Adjustment    Adjust Powerfoot to correct 
    height setting
  Hose not attached to suction opening    Grasp Quick Reach Handle and 
      firmly push Hose Wand onto the 
    suction opening
  Twist ‘n Snap Hose not securely attached    Make sure Twist ‘n Snap Hose is 
      snapped into locked position
  Crack or hole in Hose    Check Hose and replace if needed
  Broken or worn Drive Belt    Replace Drive Belt, see pg. 10
  Rotating Floor Brush bristles worn    Replace brush
  Rotating Floor Brush jammed    Remove brush and clean debris from 
    brush ends
  Clog in vacuum    Clear clog, see pg. 11
  Dirt Container full    Empty Dirt Container
  Dirt Container not installed properly    Position correctly and lock in place
  Filters are dirty    Check and clean Inner and Outer 
      Circular Filters, Pre-Motor and 
    Post-Motor Filters
  Louvers missing or installed incorrectly    Check for a clog in the tube in the 
      center of the Dirt Container, clear
      and properly install Louvers 
Tools wont pick up dirt
Possible Cause  Remedies
  Crack or hole in Hose    Check Hose and replace if needed
  Clog in vacuum    Clear clog, see pg. 11
11
22
11
22
33
99
77
88
44
55
66
1010
 WARNING: To reduce the risk of injury 
from moving parts and/ 
or electrical shock, turn 
Power Switch OFF and 
disconnect polarized plug 
from electrical outlet 
before performing 
troubleshooting checks.
1111
1212
11
22 
						

							Tools wont pick up dirt, continued
Possible Cause  Remedies
  Dirt Container full    Empty Dirt Container
  Dirt Container or Upper Tank     Position correctly and 
  not installed properly    lock in place
  Filters are dirty    Check and clean Inner and Outer
      Circular Filters, Pre-Motor and 
    Post-Motor Filters
  Louver missing or installed incorrectly    Check for a clog in the tube in the 
      center of the Dirt Container, clear 
      and properly install Louvers
Vacuum cleaner is difficult to push
Possible Causes  Remedies
  Incorrect Height Adjustment    Adjust Powerfoot to correct 
    height setting
  Brush Cover installed incorrectly    Make sure all three latches 
    are secured
Visible dirt escaping from cleaner
Possible Causes  Remedies
  Dirt Container full    Empty Dirt Container
  Filters missing or installed incorrectly    Check Inner and Outer Circular 
      Filters and Post-Motor Filter for 
    correct installation
  Dirt Container installed incorrectly    Pull out and re-insert Dirt 
    Container correctly
  Filter Cup installed incorrectly    Remove Dirt Container and make 
      sure Filter Cup is fully attached
If suggested solutions do not correct the problem, call:
BISSELL Consumer Services
1-800-237-7691 
Monday - Friday  8 a.m. — 10 p.m. ET
Saturday    9 a.m. — 8 p.m. ET
or visit the BISSELL website - www.bissell.com
Troubleshooting Continued
33
44
55
66
11
11
22
33
22
44
13 
						

							14
Replacement Parts – BISSELL PowerForce Bagless Series
You may purchase replacement parts from your retailer, by calling BISSELL Consumer Services 
or by visiting our website. To locate a retailer near you, or to place an order using Visa, 
MasterCard, Discover or American Express, call
BISSELL Consumer Services
1-800-237-7691 
Monday - Friday  8 a.m. — 10 p.m. ET
Saturday    9 a.m. — 8 p.m. ET
Or visit our Website - www.bissell.com
 
Item  Part No.  Part Name
 1  32074  Style 7/9/10 Drive Belt (2-Pack)
 2    203-1007  Large Headlight Bulb (Select Models Only)
 3    203-1297  Standard Headlight Bulb (Select Models Only)
 4    203-1063   Crevice Tool
 5    203-1099  Combination Dusting Brush / Upholstery Tool 
 6    203-1022   Extension Wand
 7    203-1216  Wire Reinforced Twist ‘n Snap Vacuum Hose 
 8    203-1195   Wide Brush Roll 
 9    32064  Style 9/10 Inner & Outer Circular Filter Set
10   32065  Style 9/10 Inner Circular Filter only
11   32066  Style 10 Outer Circular Filter and Post-Motor Filter Set
12   203-1215   Pre-Motor Filter
12/3456
7 891011
12 
						

							BISSELL Consumer Services
For information about repairs or replacement parts, or 
questions about your warranty, call:
BISSELL Consumer Services
1-800-237-7691 
Monday - Friday   8 a.m. — 10 p.m. ET
Saturday    9 a.m. — 8 p.m. ET
Or write:
BISSELL Homecare, Inc.
PO Box 3606
Grand Rapids,  MI 49501
ATTN:  Consumer Services 
Or visit the BISSELL website - www.bissell.com
When contacting BISSELL, have model number of unit available.
Please record your Model Number: ___________________
Please record your Purchase Date:  ___________________
NOTE: Please keep your original sales receipt. It is your warranty.
15 
						

							Warranty
16
This warranty gives you specific legal rights, and you may also have other rights which may vary from state to 
state. If you need additional instruction regarding this warranty or have questions regarding what it may cover, 
please contact BISSELL Consumer Services by E-mail, telephone, or regular mail as described below.
Limited One Year Warranty
Subject to the *EXCEPTIONS AND EXCLUSIONS identified below, upon receipt of the product BISSELL Homecare, 
Inc. will repair or replace (with new or remanufactured components or products), at BISSELL’s option, free of 
charge from the date of purchase by the original purchaser, for one year any defective or malfunctioning part.
See information below on If your BISSELL product should require service.
This warranty applies to product used for personal, and not commercial or rental service. This warranty does not 
apply to fans or routine maintenance components such as filters, belts, or brushes. Damage or malfunction caused 
by negligence, abuse, neglect, unauthorized repair, or any other use not in accordance with the Users Guide is 
not covered
. 
If your BISSELL product should require service:
Contact BISSELL Consumer Services to locate a BISSELL Authorized Service Center in your area. 
If you need information about repairs or replacement parts, or if you have questions about your 
warranty, contact BISSELL Consumer Services.
Website or E-mail:
www.bissell.com
Use the “Customer Services” tab
.
Or Call:
BISSELL Consumer Services
1-800-237-7691
Monday - Friday 8 a.m. - 10 p.m. ET
Saturday 9 a.m. - 8 p.m. ET 
Or write:
BISSELL Homecare, Inc.
PO Box 3606
Grand Rapids MI 49501
ATTN: Consumer Services
BISSELL HOMECARE INC. IS NOT LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGES OF ANY 
NATURE ASSOCIATED WITH THE USE OF THIS PRODUCT. BISSELL’S LIABILITY WILL NOT EXCEED THE 
PURCHASE PRICE OF THE PRODUCT. 
Some states do not allow the exclusion or limitation of incidental or consequential damages, so the 
above limitation or exclusion may not apply to you. 
*EXCEPTIONS AND EXCLUSIONS FROM THE TERMS OF THE LIMITED WARRANTY
THIS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES EITHER 
ORAL OR WRITTEN. ANY IMPLIED WARRANTIES WHICH MAY ARISE BY OPERATION 
OF LAW, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND 
FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO THE ONE YEAR DURATION 
FROM THE DATE OF PURCHASE AS DESCRIBED ABOVE.
Some states do not allow limitations on how long an implied warranty lasts, 
so the above limitation may not apply to you.
©2004 BISSELL Homecare, Inc
Grand Rapids, Michigan
All rights reserved. Printed in Korea
Part Number 603-2558
Rev 10/05 
Visit our website at:
www.bissell.com