Apple powerbook firewire User Manual

Display Cable Take Apart
PowerBook (FireWire)
514 . Remove the two black 
Phillips screws on the 
right clutch.
5 . Remove the two black 
Phillips screws on the 
right brace.
6. Remove the two silver 
Phillips screws on the 
right antenna ground, 
deroute the antenna, 
and move it out of the 
way.
7. Lift the LCD panel away 
from the bezel.
8. Pull the display cable 
tab off its retaining 
post on the clutch.
9 . Peel up the end of the 
tape on the display 
cable and unwind it 
from the clutch.
1 0 ....

Display Cable Take Apart
PowerBook (FireWire)
52
Display Cable 
Replacement
1 . Connect the display 
cable to the back of the 
LCD panel.
2. Lay the clutch/brace 
on top of the cable and 
fit the holes in the 
display cable tab over 
the posts on the clutch.
3. Wrap the cable away 
from you and over the 
clutch twice. The 
second wrap will slide 
inside the first wrap 
and the ferrite bead 
will lie under the part 
of the clutch that 
connects to the bottom 
case.
4 . Wrap the adhesive tape 
around the...

LCD Panel Take Apart
PowerBook (FireWire)
53
LCD Panel
Before you begin, remove 
the following:
¥ display module
¥ display housing
¥ wireless antenna
¥ display cable (through 
step 6 only of the 
Display Cable Take 
Apart procedure)
1 . Remove the two black 
Phillips screws on the 
left clutch.
2. Remove the remaining 
black Phillips screw 
on the left brace.
3. Lift the LCD panel away 
from the bezel. 

LCD Panel Take Apart
PowerBook (FireWire)
544 . Remove the two black 
T-8 screws on the 
sides of the display 
brackets (two on the 
left bracket and two on 
the right bracket).
Replacement Notes: Lay 
the two wires of the 
backlight cable on the back 
side of the clutch. Place the 
antenna cable on the side of 
the clutch closest to you 
with the ridge between the 
backlight cable wires and 
the antenna cable. The 
backlight wires should 
extend 8.0 mm past the end 
of the clutch. 
Slide the clip over...

Microphone Take Apart
PowerBook (FireWire)
55
Microphone
Before you begin, remove 
the display housing.
1 . Disconnect the 
microphone cable from 
the microphone card. 
2. Pull the microphone 
out of its holder and 
peel the microphone 
card off the bezel. 

 
Apple Service Source 
PowerBook (FireWire)
1 
Additional Procedures
 
Sprung I/O Door Repair Procedure 
An I/O door is sprung if it will not close all the way and has no 
snap to it. It is not necessary to take the unit apart to get the 
door back on its spring. 

 
Sprung I/O Door Repair Procedure Additional Procedures 
PowerBook (FireWire)
21 . Grasp the top and 
bottom edges of the I/O 
door in the center of 
the door.
2. Pull the I/O door away 
from the back of the 
computer in an even 
motion, keeping the 
bottom and the top of 
the door aligned. It may 
be necessary to hook 
the bottom lip of the 
I/O door with a 
fingernail to avoid 
tilting the door.
3. Pull the I/O door out 
approximately five to 
ten millimeters (0.2 
to 0.5 inches) from the 
I/O wall...

 
Apple Service Source 
PowerBook (FireWire)
1 
PowerBook (FireWire) 
Exploded View
 
The Exploded View chapter includes a general exploded view showing the 
major parts of the computer and their part numbers; a display exploded 
view; reassembly checksheets; and screw locators. 

 
Exploded View 
PowerBook (FireWire)
2 
PowerBook (FireWire) Main Exploded View 
Bottom Case 
922-4179  
Battery
661-2295
DVD-ROM
661-2244
I/O Logic Board
661-2286
Power Supply Card
661-2287
Yoke 922-3832Latch Spring
922-3849
Stiffener
922-4180
I/OEMI Shield
922-4195 Wireless
Antenna Connector
Holder 922-4203Modem,V.90 
US/CAN/JPN
661-2309
	 	 	 
Modem EMI Filter
922-4175
RJ-11Cable/Phone Jack 
922-3845	
Reset Button 
922-4202
Fan 922-4194
Sound Card 
661-2288
Microprocessor Board
400 MHz 661-2284
500...

 
Exploded View 
PowerBook (FireWire)
3 
PowerBook (FireWire) Display Exploded View 
PowerBook (FireWire) Display Exploded View
Screw Cover 
922-3823 Clutch/Brace, 
Wire Side 
922-4181 
Display Housing
922-4183
14.1 Display
661-2290 (LG)
661-2289 (Samsung)
 
Backlight
 Cable Clip
922-3846
Microphone
922-4172 Clutch/Brace,
Flex Side 
922-4182
Display Bezel 
922-4199 
Bumper	
922-3824Display Cable
922-4171 (LG)
922-4190 (Samsung)
Wireless Cable Antenna
922-4173
Wireless Antenna
Cable Backlight
Cable...