Apple ibook g4 early 2004 User Manual

 © 2003 Apple Computer, Inc. All rights reserved. 

 
 
 
Service SourceiBook G4
 
iBook G4
iBook G4 (Early 2004)
 
Updated July 1, 2005 

 
© 2003 Apple Computer, Inc. All rights reserved. 

 
 
 
Service Source
 Take Apart
 
                                               iBook G4
iBook G4 (Early 2004) 

 
iBook G4 Take Apart -   
2  
 General Information 
General Information
 
Overview
 
To easily distinguish this computer from previous iBook models, note these characteristics:
• iBook G4 identifier on display bezel
• Slot-load optical drive 
  
• Mac OS X version 10.3 operating system 

 
3 -  
iBook G4 Take Apart
 General Information The ports on the left side of the computer are
• RJ11 modem port
• Ethernet port
• FireWire port
• Two USB ports
• External display connector
• Headphone port 
  
This table shows the iBook G4 product configurations at initial product introduction:  
* 
 For servicing the 14.1-inch models, refer to the iBook G4 (14-inch) service manual.
This table shows the iBook G4 (Early 2004) product configurations at initial product 
introduction:    
* 
 For servicing...

 
iBook G4 Take Apart -   
4  
 General Information 
New Procedures
 
If you are familiar with taking apart iBook computers, you will notice some differences with 
this iBook model:
• Slot-load optical drive
• AirPort Extreme Card option
• Bluetooth option
• The number and types of screws differ somewhat from previous models.  
Note:  
 The top and bottom EMI shields are now marked with screw identifiers for most of 
the screw locations. The screw identifiers are in the form of M2x_ where the last digit...

 
5 -  
iBook G4 Take Apart
 General Information 
Serial Number Location
 
In this computer, the product serial number is located in two places:
• Battery bay 
• Top case underneath the keyboard 

 
iBook G4 Take Apart -   
6  
 Battery 
Battery
 
Tools
 
The only tool required for this procedure is a coin. 
Part Location
Preliminary Steps
 
Warning:  Always shut down the computer before opening it to avoid damaging its 
internal components or causing injury. After you shut down the computer, the 
internal components can be very hot. Let the computer cool down for 30 minutes 
before continuing. 
Procedure
 
Warning: 
  If the computer has been recently operating, allow it to cool down before...

 
7 -  
iBook G4 Take Apart
 Battery 3. Disconnect the power cord and any other cables connected to the computer.
4. Close the computer, turn it over, and locate the battery latch.
Use a coin to turn the battery latch 1/4 turn clockwise to unlock the battery. Gently 
remove the battery.
Removing the battery will prevent you from accidentally turning on the computer. 
Warning: Removing the battery before shutting down the computer may result 
in data loss. 
5. Install the replacement battery.
6. Reconnect...

 
iBook G4 Take Apart -   
8  
 Foot and Foot Socket 
Foot and Foot Socket
 
Tools
 
• Foot kit
• Soft cloth
• Needlenose pliers
• #0 Phillips jeweler’s screwdriver 
Caution: 
  To avoid scratching the case, use caution when using tools to remove and 
replace the foot and foot socket. 
Part Location
Preliminary Steps
 
Warning:  Always shut down the computer before opening it to avoid damaging its 
internal components or causing injury. After you shut down the computer, the 
internal components can be...

 
9 -  
iBook G4 Take Apart
 Foot and Foot Socket 
Procedure
 
1. Place the computer on a clean, flat surface or soft cloth.
2. Shut down the computer and wait thirty minutes before continuing. 
3. Disconnect the power cord and any other cables connected to the computer.
4. Close the computer, turn it over, and locate the foot that needs replacement.
5. 
Caution: 
  To avoid scratching the case, use caution when using tools to remove and 
replace the foot.
If any portion of the rubber foot remains on the...