AirComm Corporation Bell Air Conditioner206L L1 L3 Single Dual evap L4 Single evap only Installation Instructions Insert ORing

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
Revision F       January 19, 2015 
1575 W. 124th Ave., Westminster CO 80234 Tel 303-440-4075 | Fax 303-440-6355 http://www.aircommcorp.com/ | [email protected] 
 
 
 
 
 
 
 
AIR COMM CORPORATION  
1575 W. 124th Avenue 
WESTMINSTER, CO. 80234 
PHONE: 303-440-4075 FAX: 303-440-6355 
[email protected] 
 
 
 
INSTRUCTIONS FOR CONTINUED AIRWORTHINESS 
BELL HELICOPTER 206L, L1, L3 
AIR CONDITIONING SYSTEM  
 
 
 
 
THIS HANDBOOK INCLUDES THE...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F Page ii 
 
 
 
 
 
 
 
 
 
 
 
RESTRICTED DISCLOSURE NOTICE 
 
THIS PUBLICATION IS THE PROPRIETARY INTELLECTUAL PROPERTY OF AIR COMM 
CORPORATION AND IS DELIVERED TO THE RECIPIENT WITH THE EXPRESS CONDITION 
THAT IT AND THE INFORMATION CONTAINED HEREIN ARE NOT TO BE USED, DISCLOSED 
OR REPRODUCED IN PART OR IN WHOLE, FOR ANY PURPOSE WITHOUT THE EXPRESS 
WRITTEN CONSENT OF AIR COMM CORPORATION. NO RIGHT IS GRANTED TO THE 
RECIPIENT TO...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F Page iv 
 
LIST OF EFFECTIVE PAGES 
 
LIST OF EFFECTIVE PAGES 
 
Title Page(s) Revision No. 
Record of Revisions  iii F 
List of effective Pages  iv F 
Table of Contents  v - vi F 
Chapter 1 Introduction  1-6 F 
Chapter 2 Airworthiness Limitation Section  7 F 
Chapter 3 Inspections  8-12 F 
Chapter 4 Location and Access 13-20 F 
Chapter 5 Placards and Markings 21-23 F 
Chapter 6 Servicing 24-27 F 
Chapter 7 Standard Practices  28-41...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F Page v 
TABLE OF CONTENTS 
 
Chapter   Page 
 
CHAPTER 1 ..................................................................................................................................... 1 
INTRODUCTION .......................................................................................................................... 1 
1....

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F Page vi 
6. REMOVE AND REPLACE COMPRESSOR DRIVE BELT (Figure 12) ............................. 31 
7. REMOVE AND REPLACE COMPRESSOR DRIVE PULLEY (Figure 12) ........................ 34 
8. REMOVE AND REPLACE FORWARD EVAPORATOR (Figure 13) ................................. 34 
9. REMOVE AND REPLACE AFT EVAPORATOR (Figure 14) ............................................ 35 
10.  REMOVE AND REPLACE AFT EVAPORATOR BLOWER (Figure 14)...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F  Page 1 
 
CHAPTER 1 
INTRODUCTION  
1. SCOPE 
The scope of this manual encompasses the scheduled and unscheduled maintenance 
procedures for the continued airworthiness of the Air Comm Corporation air conditioning 
system installed in the Bell 206L, L1,L3 series helicopter. 
2. PURPOSE  
The purpose of this manual is to provide the aircraft mechanic in the field the necessary 
information to maintain the air conditioning system....

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F  Page 2 
 
Refrigerant: A fluid which is used in an air conditioning system to absorb heat from the 
cabin and carry it outside the helicopter where it can be transferred to the outside air. 
Relative humidity: The ratio of the amount of water vapor in the air to the amount of water 
vapor required to saturate the air at the existing temperature. 
Thermostat: An air conditioning control which senses the temperature of the evaporator...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F  Page 3 
 
7. PRECAUTIONS 
The following precautions are found throughout this manual, and will vary depending on the 
seriousness of the Hazard or Condition: 
WARNING: May be a maintenance procedure, practice, condition, etc., which could result 
in personal injury or loss of life. 
CAUTION: May be a maintenance procedure, practice, condition, etc., which could result in 
damage or destruction of equipment. 
NOTE: May be a...

INSTRUCTIONS FOR CONTINUED AIRWORTHINESS - 206EC-202M-1 
 
 
Revision F  Page 4 
 
 
12. CHANGES TO INSTRUCTIONS FOR CONTINUED AIRWORTHINESS 
 Changes made to a line or paragraph of this document will be indicated by a vertical bar in 
the right hand margin, while a complete page change will be indicated by a vertical bar next 
to the page number. 
(Example: Any change will appear with a vertical bar next to that change). 
13. SYSTEM DESCRIPTION AND OPERATION 
 The 206EC-206 system is a vapor cycle type...