Brother Hl 3260n User Manual

CHAPTER 5 MAINTENANCE
5-13
C C
l l
e e
a a
n n
i i
n n
g g
Clean the printer exterior and interior periodically with a dry soft cloth. When
you replace the toner bottle, be sure to clean the printer interior with a dry
soft cloth. If the printed page gets stained with Toner, clean the printer
interior with a dry soft cloth.
War ni ng
• Turn off the printer power and allow it to cool down before cleaning.
! Cleaning the Paper feed roller
If the paper feed rollers are dirty with paper dust, the paper may...

5-14
☛
☛☛ ☛ 3.Locate the position of the Paper feed rollers as shown in the illustration
below.
ZAEM400E 
Fig. 5-24
☛
☛☛ ☛ 4.Lift the green lever that is attached to the Paper feed rollers inside the
printer on the lower right hand side and pull it towards you.
ZAEM090E 
Fig. 5-25
☛
☛☛ ☛ 5.Pull the Paper feed roller towards you (), then push it in a diagonally
downward direction away from you and remove it ().
ZAEM100E 
1
2
Fig. 5-26
 

CHAPTER 5 MAINTENANCE
5-15
☛
☛☛ ☛ 6.Wipe the rubber of the Paper feed roller with a dry cloth.
ZAEM031E 
Fig. 5-27
✒
✒✒ ✒  Note
• Do not wipe with a wet cloth, alcohol or cleanser.
☛
☛☛ ☛ 7.Insert the projection of the Paper feed roller into the hole ().  While pulling
the roller towards you, insert the roller onto the rear shaft ().
ZAEM110E 
1
2
2
Fig. 5-28
☛
☛☛ ☛ 8.Check the motion of the Paper feed roller to confirm that it can rotate
smoothly.
ZAEM101E 
Fig. 5-29
 

5-16
☛
☛☛ ☛ 9.Return the green lever to its original position.
ZAEM091E 
Fig. 5-30
☛
☛☛ ☛ 10.Clean the paper feed rollers of Paper tray 2 by following steps 2 to 8.
☛
☛☛ ☛ 11.Hold Paper tray 2 (which has a lever on the paper size dial) with both hands,
and slide it slowly into the second slot from the top until it stops.
ZAEM141E 
Fig. 5-31
☛
☛☛ ☛ 12.Hold Paper tray 1 with both hands, and slide it slowly into the slot until it
stops.
☛
☛☛ ☛ 13.If the optional Lower tray (LT-5100 or LT-5200) is installed,...

CHAPTER 5 MAINTENANCE
5-17
! Cleaning the Friction pad
If the Friction pads are dirty, the printer may feed multiple pages or paper
jam.  In this case, clean the Friction pads of each paper tray.  Follow these
steps to clean the Friction pads in standard Paper tray 2.
☛
☛☛ ☛ 1.Turn off the printer power.
☛
☛☛ ☛ 2.Slide Paper tray 2 out until it stops.
ZAEY012E 
Fig. 5-32
☛
☛☛ ☛ 3.Wipe the top of the Friction pad with a dry cloth.
ZAEY017E 
Fig. 5-33
✒
✒✒ ✒  Note
• Do not wipe with a wet cloth, alcohol or...

5-18
! Cleaning the Pad inside the Paper tray
If the Pad inside the paper tray is dirty multiple pages may print when a
small amount of paper is stacked. In this case, clean the Pad inside the
paper tray.  Follow these steps to clean the Pad inside standard Paper tray 2.
☛
☛☛ ☛ 1.Turn off the printer power.
☛
☛☛ ☛ 2.Slide Paper tray 2 out until it stops.
ZAEY012E 
Fig. 5-34
☛
☛☛ ☛ 3.If there is paper in the Paper tray, remove the paper.
☛
☛☛ ☛ 4.Wipe the pad inside the Paper tray with a dry cloth....

CHAPTER 5 MAINTENANCE
5-19
☛
☛☛ ☛ 5.Load paper and slide Paper tray 2 into the printer slowly until it stops.
☛
☛☛ ☛ 6.If the 2000 Sheets paper tray (LT-5200) is installed, clean the Friction pads
of Paper tray 3 or Paper tray 4 following the steps for Paper tray 1 and Paper
tray 2.
 

5-20
A A
d d
d d
i i
n n
g g
   
S S
t t
a a
p p
l l
e e
s s
When the message “Add Staples” appears on the Control panel, the staples have run
out. Follows these steps to add a new staple refill.
✒ Note
After adding the Staple refill, Staples might not be ejected for the first few
times.
☛
☛☛ ☛ 1.Open the Rear cover of the Finisher.
Fig. 5-36
☛
☛☛ ☛ 2.Remove the empty cartridge.
Fig. 5-37
 

CHAPTER 5 MAINTENANCE
5-21
☛
☛☛ ☛ 3.Remove the empty refill case as shown in the illustration.
ZAEH190E 
Fig. 5-38
☛
☛☛ ☛ 4.Align the arrows on the new refill case and the cartridge, and push the new
refill case in until it clicks.
ZAEH191E 
Fig. 5-39
✒ Note
Do not remove the ribbon securing the staples before installing the
cartridge.
 

5-22
☛
☛☛ ☛

	

	








		

	
	
	
	

			
	


	

	

	


		
	

		
ZAEH200E 
Fig. 5-40
☛
☛☛ ☛


		




Fig. 5-41
☛
☛☛ ☛